Professional Documents
Culture Documents
Top
Member K factor
Registered:
08/19/08 Please notice that this is a new feature on PV Elite 2009
Posts: 82
Loc: Houston,TX, _________________________
USA Best Regards,
Luis Sanjuan
CADWorx & Analysis Solutions
http://65.57.255.42/ubbthreads/ubbthreads.php?ubb=showflat&Number=26852 1/4
4/13/2017 NozzleReinforcementInEllipticalHeadIntergraphCADWorx&Analysis
Top
Re: Nozzle Reinforcement In Elliptical Head [Re: Luis #26866 04/22/09 11:38 AM
Sanjuan]
Scott_Mayeux Istvan,
The use of 0.9 or 1.0 in the formula depends on the location of the
Member nozzle in the head. If the nozzle and its reinforcement limit lie within
the spherical part of the head, the required thickness of the ellipse
Registered:
12/23/99 (spherical portion) can be computed as a sphere (K = 0.9), otherwise
Posts: 338 the nozzle or its reinforcement lies within the knuckle region and the
Loc: value of tr is computed as if the head were a regular ellipse. So, you
Houston,TX,USA
need to check the input and make sure all of your calculations are "on
the same page".
Top
Is this correct?
BTW even if the diameter was the o/d, the wall thickness is 12 so o/d
http://65.57.255.42/ubbthreads/ubbthreads.php?ubb=showflat&Number=26852 2/4
4/13/2017 NozzleReinforcementInEllipticalHeadIntergraphCADWorx&Analysis
is 938.4, 80% of that is 750.72 which is still smaller that the diameter
limit 774.
_________________________
Regards,
Istvan
Top
You can also reduce the diameter limit (if possible) where it does not
cross into the knuckle. In this manner, you get the extra area in the
shell using the 0.9 factor.
Top
Member Thank you for your help. I've learned something again. :)
Registered:
02/09/07 Thanks again
Posts: 11
Loc: Newbury, UK Istvan
_________________________
Regards,
Istvan
Top
Tweet
http://65.57.255.42/ubbthreads/ubbthreads.php?ubb=showflat&Number=26852 3/4
4/13/2017 NozzleReinforcementInEllipticalHeadIntergraphCADWorx&Analysis
Like SignUptoseewhatyourfriendslike.
Generated in 0.036 seconds in which 0.005 seconds were spent on a total of 15 queries. Zlib compression disabled.
Powered by UBB.threads PHP Forum Software 7.5.7
http://65.57.255.42/ubbthreads/ubbthreads.php?ubb=showflat&Number=26852 4/4