Professional Documents
Culture Documents
exchangers.
2. To prevent from burning the tubes, all tubes in the boiler must be filled with water
3. The reheater raises the temperature and pressure of the steam again after it
5. Saturated steam enters the LTSH after leaving the boiler drum.
6. The steam that have been condensed to water is called boiler feedwater.
7. The radiant RH is located in the furnace walls (front and side walls)
8. After steam perform work in the turbine extractions are necessary in order to give
9. The steam drum acts as a disturbing and collecting point of for water and steam.
10. Water wall tubes of the furnace are in the radiant zone of the boiler.
11. A boiler is designated to transfer maximum combustion heat energy into the
feedwater heaters.
12. The SH Division Panel is located in the hottest part of the boiler.
15. The temperature of the steam entering the HP steam turbine is closely controlled
17. Pressure in the SH Desuperheater are lower than the SH pressure in order to
18. The flow of steam to the HP Turbine is from low to high pressure to match the HP
Turbine requirements.
19. Some boilers have both radiant and convection superheaters and reheaters.
20. The steam leaving the boiler must be superheated to match the HP
requirements.