Professional Documents
Culture Documents
Before applying hoist to underbody, always take vehicle balance throughout service into
consideration. Vehicle balance on hoist may change depending on what part to be removed.
Before lifting up the vehicle, check to be sure that end of hoist arm is not in contact with brake pipe,
fuel pipe, bracket or any other part.
When using frame contact hoist, apply hoist as shown (right and left at the same position). Lift up
the vehicle till 4 tires are a little off the ground and make sure that the vehicle will not fall off by
trying to move vehicle body in both ways. Work can be started only after this confirmation.
Make absolutely sure to lock hoist after vehicle is hoisted up.
:2
:3
I5RW0A010001-02
In raising front or rear vehicle end off the floor by jacking, Vehicle Identification Number
be sure to put the jack against engine front mounting S6RW0C0101006
member (1) or rear jacking bracket (2). The number is punched on the front dash panel in
engine room and it is also attached on the left side of
1 instrument panel depending on the vehicle specification.
I5RW0C010002-01
2
I5RW0A010002-02
[B]
I4RS0A010008-01
2
1
I5RW0A010003-03