Professional Documents
Culture Documents
ARCHITECTURAL COATINGS
TOUCHWOOD
www.asianpaints.com/oman NC Primer Surfacer
PRODUCT DESCRIPTION
BERGER Touchwood NC primer Surfacer is a high quality nitro-cellulose based quick drying primer, recommended
for interior wood finishes.
This is designed to be used over natural wood , ply and partical board before application of N.C. Pigmented top coat
Besides protection, it gives rich finish to the top coat.
TECHNICAL DATA
Shade / Colour Range : White / Grey
Composition Nominal : One component NC based.
Specific gravity : 1.35 + 0.02
% Volume Solids : 35 2 %
APPLICATION DATA
SURFACE PREPARATION
Proper surface preparation is important to get a good finish. Sand the wooden surface and clean free of any dirt or grease.
Use Touchwood wood Filler to fill the grains of the wood. Sand and remove excess wood filler.
Allow the surface to dry for 1 - 2 hrs. Sand mildly with Emery paper 400.
Apply 2 - 3 coats depending upon the grain size and type of wood used.
For dark colour top coat, use NC Primer Grey and for light colour top coat used NC Primer White.
* For detailed system recommendation based on specific requirements please contact Berger representative.
DISCLAIMER
The information provided in this data sheet is not intended to be complete. It is the responsibility of the user to ensure that the product used is suitable for the purpose it is meant to serve.
In view of various factors affecting the performance of the coating, we cannot assume responsibility for the product performance, nor do we accept any liability arising from use of this
product, unless specifcally agreed to in writing by us. The information provided in the datasheet may be modifed by us without notice.
This Technical Data Sheet supersedes those previously issued with immediate effect.
Version: 02/2007