You are on page 1of 4

1- What is the low-pass filter?

a- it will let pass low frequencies? (or it blocks high frequency)


b- It will let pass high frequencies?
c- It will let pass a band of frequencies?
d- It will eliminate a band of frequencies?

2- What is the DC gain of the transistor NPN?


The right answer is IC/IB, they put also the formulas of the Mosfet which are wrong for this
question

3- What is the role of the zener diode?


a- Rectification
b- Amplification
c- voltage regulation

4- How the diode let pass the current?


Only in one way, it will block the other way

A small problem where u have to determine the number of poles of a synchronous motor, if
you know the pulsation ws (rad/sec) & speed Ns (RPM) and the frequency f (Hz)

&

5- In case of Transformer saturation how the efficiency and the no load current will behave?
(efficiency decrease and current output is similar to the magnetic field in the transformer
and chopped with notches)

6- Ohms Law (the right one is U=RI, they put choices not related to this law)

7- The best mix around an earth electrode (Lime sand mixture? Coal & Salt? Etc the right
choice is sand mixture with copper mulch)

8- The best place to build an exhibition and convention center (near the Airport? Or in satellite
place far from Urban? Etc)

9- What is the circuit breaker application? Its basic function is to detect a fault condition and
interrupt current flow.

10- Power transformers are generally designed to have maximum efficiency around:
a- No load
b- half load
c- near full load
d- over load

11- Which breakers used as the main circuit breakers of power distributions in buildings:
a- ACB
b- VCBs
c- oil circuit breakers
12- Which type of motor used in home ceiling fan:
a- capacitor motor
b- shaded pole motor
c- universal motor

13- A synchronous motor on No-load can be used as:


a- synchronous condenser
b- induction motor
c- induction generator

14- Running along the top of transmission line is:


a- ground conductor
b- line conductor

15- Minimum cross sectional area of earth continuity conductor in buildings used:
a- 20 AWG
b- 16 AWG = 1.5 mm2
c- 12 AWG
d- 10 AWG

16- A critical path is the ----------------------in the project management:


a- longest
b- shortest
c- none

17- For power factor correction of power systems which one is used:
a- capacitor
b- inductor
c- resistors

18- terminals of a transistor (BJT):


a- Base, collector & emitter
b- gate, collector & emitter
c- gate, emitter & drain

19- Differential Amplifier with High CMRRS means:


a- High rejection of noise
b- Amplify noise
c- High amplification gain

20- High voltage winding of transformer has ---------- resistivity than the low voltage side.
a- Lower
b- Higher
c- Equal
d- Lower or Equal

21- CMOS inverter is superior to the R-pull up inverter due to:


a- Smaller propagation Delay

22- Which type of motor used in ceiling fan?


a- Capacitor start type
b- Permanent capacitor run
c- Capacitor induction run.

23- ABET stands for Accreditation Board for Engineering and Technology?
a- True
b- False
24- What does the power factor stands for:
a- Cosine of the angle between voltage and current.
b- Sine of the angle between voltage and current.
c- Apparent power over real power.

25- If the induction motor speed at no-load is 745 RPM, what is the speed of the motor:
a- 700 RPM
b- 750 RPM
c- 800 RPM
d- 850 RPM

26- What are the type of losses inside the alternator:


a- Armature losses
b- Winding losses

27- If a sudden excitation happens to the alternator what will be its effect:
a- Variation in real power on load side.
b- Variation in apparent power on load side.
c- Power factor effects.
d- The frequency of the generated wave form will be affected.

28- Op-amp (operational amplifier) input resistance:


a- Zero
b- Infinity
c- Relative resistance
d- Same output resistance.

29- For an inverter op-amp, what will be the equivalent output resistance?
a- Zero
b- Infinity
c- Relative forward resistance
d- Same as the input resistance.

30- Which of the following devices has a metalsemiconductor junction formed between a metal
and a semiconductor:
a- schottky diode
b- zener diode
c- varactor diode
d- tunnel diode

31- The heat loss inside a straight conductor is 60J upon applying current I for 5s. if the
resistance of the conductor is decease to half, and the same current is applied for 5s, what
will be the heat dissipation:
a- 60J
b- 30J
c- 15J
d- 120J

32- Project Scope Management:


a- Define scope and control scope
b- Executing scope and verify scope
c- Closing process and Create work breakdown structure
d- All of the above
e- Only A & B
33- The forward pass review of the project management will indicate the following:
a- The earliest start of the task
b- The earliest finish of the task
c- Critical path (longest path)
d- Only A & B
e- All of the above

34- The back pass review of the project will indicate the following:
a- The latest start of the task.
b- The earliest finish of the task.
c- The critical path.
d- Only A & C
e- All of the above.

35- Invertor allowed noise level question given the values of VOH, VOL, VIH, VIL. And need to
get NMH and NML

36- Which of the transmission voltage is not applied in Qatar Electrical Specs:
a- 66KV
b- 132KV
c- 220KV
d- 400KV

You might also like