Professional Documents
Culture Documents
Expanded Graphite
SIGRAFLEX ENONOMY
Graphite foil
is a bonded sealing sheet made from flexible
Stainless steel foil
graphite foil with one or two 0.05 mm thick
Cross-section
Applications
P
For pumps and fittings, preferably in small Approvals
gasket thicknesses P BAM oxygen
P
For unstable flanges with low gasket stresses P DVGW (DIN 3535-6)
and for waste gas pipelines, e.g. in incineration
plants
P
For raised-face flanges meeting DIN EN 1514
and DIN 2690
P
For low internal pressures of up to 40 bar
P
For corrosive media
P
Suitable for a broad range of temperatures from
250C to approx. 550C under consideration
of the chemical resistance; for applications at
more than 450C, users should request our
advice
To ensure a correct and defect-free assembly,
Properties please ask for our detailed assembly instructions.
P
Excellent oxidation resistance
P
Soft, highly adaptable
P
Good chemical resistance Compressibility of SIGRAFLEX ECONOMY
P
Long-term stability of compressibility and
recovery, even under fluctuating temperatures
P No measurable cold or warm flow characteristics
up to the maximum permissible gasket stress
Gasket thickness [mm]
Definitions
sVU/0.1 Minimum gasket assembly stress needed to comply with leakage k1 In mm, factor for gasket stress in service
class L 0.1 (according to DIN 28090-1) KD In N/mm2, max. gasket stress-bearing capacity under assembly
Recommended gasket assembly stress: 20 N/mm2 up to sBO conditions
sBU Minimum gasket assembly stress in service, where sBU is the product KSW Compression set under a gasket stress of 35 N/mm
of internal pressure p and gasket factor m for test and in service KRW Gasket recovery after reduction in gasket stress from 35 N/mm
(sBU = p m) to 1 N/mm
sVO Maximum permissible gasket stress at 20C WSW Gasket creep compression under a gasket stress of 50 N/mm
sBO, 300C Maximum permissible gasket stress in service at 300C after 16 h
m sBU/pi WRW Recovery after reduction in gasket stress from 50 N/mm to 1 N/mm
m factor Similar to m, but defined according to ASTM, hence different value
y factor Minimum gasket stress in psi The percentage changes in thickness of KSW, KRW, WSW and WRW are relative to
k0 In mm, factor for gasket assembly stress the initial thickness.
Product overview
Graphite Specialties
SGL CARBON GmbH
Werner-von-Siemens-Str. 18
86405 Meitingen/Germany
Phone +49 8271 83-2276
Fax +49 8271 83-2419
expandedgraphite@sglcarbon.de
www.sigraflex.eu
www.sglgroup.com