You are on page 1of 2

1. Strain Unit?

a. Dimension less
b. PI
c. Pa
d. N/mm2

2. What is the function of the manometer?

3. Inspection of smoke detector( NFPA 72)


a. Quarterly
b. Annually
c. Monthly
d. Semiannually

4. Water elevation on a tank is 10 meter. If P=gh and =1000kg /m3, g=9.81 m/sec. what
is the pressure of the water inside the tank:

a. 100 KPa
b. 150 KPa
c. 450 KPa
d. 981 KPa

5. If you put a cup of water in a room, the moistures will accumulate on the side of the glass when;
1. The water temperature is less than the dew point of the room air.
2. The water temperature is less than the dew point of the room air.
3. The wet bulb temperature is less than the dry bulb temperature of the room air.
4. Both the wet bulb temp and the dry bulb are the same.
a. 1 & 3
b. 2 & 3
c. 1 & 4
d. 2 & 4

6. Some questions about the Psychometric Chart.

7. The function of car bumper is:


a. Absorb high speed impacts
b. Low speed impacts
c. Side impacts
d. Decoration

8. Some questions about the NFPA 72 testing and inspections.

9. The duct installed at the side of the indoor unit of the AC unit is used for;
a. Remove the condensate water accumulated on the evaporator.
b. Remove the condensate water accumulated on the condenser.
c. Make more ventilation.
d. Cannot recall.

10. Car dashboard is made by


a. Steel
b. Polymers
c. Wood
d. ..

11. What is the most important thing in the WBS;


a. Cost
b. The project
c. Client

12. For the below system;

a. The input is a sound and the output is a signal.


b. The input is a signal and the output is a sound.
c. Both input and outputs are sounds.
d. Both input and outputs are signals.

13. What is the force that cause the body to float on the fluid surface.

You might also like