Professional Documents
Culture Documents
LOCTITE 561
December-2013
% of 72 h, 22 C Strength
LOCTITE 561 provides the following product characteristics:
Technology Acrylic 100
Chemical Type Methacrylate ester 40 C
Appearance (uncured) Off-white, wax consistencyLMS 75 22 C
Appearance (form) Stick 5 C
Fluorescence Positive under UV lightLMS 50
Components One component -
requires no mixing 25
Cure Anaerobic
Application Thread sealing 0
Strength Low 5min10min 30min 1h 3h 6h 24h 72h
Cure Time
coverage inspection.
60 or
ctivat
Noa
NSF International
Certified to ANSI/NSF Standard 61 for use in commercial and Activator 7471
40
residential potable water systems not exceeding 82 C.
20
TYPICAL PROPERTIES OF UNCURED MATERIAL
Specific Gravity @ 25 C 1.14
0
5min 10min 30min 1h 3h 6h 24h
Unworked Penetration, ISO 2137, 1/10 mm 80 to 140LMS Cure Time
150 C 3. Remove any skin that may have formed on the top of the
100 stick.
4. Apply sufficient product to fill the threads in the area
75 where the male and female threads will be engaged.
5. Recap product after use.
50 6. Using compliant practices, assemble and wrench tighten
fittings in accordance with manufacturers
25 recommendations.
0 For Disassembly
24 100 500 1000 1. Remove with standard hand tools.
Exposure Time, hours
2. In rare instances where hand tools do not work because
of excessive engagement length, apply localized heat to
nut or bolt to approximately 250 C. Disassemble while
hot.
For Cleanup
1. Cured product can be removed with a combination of
soaking in a Loctite solvent and mechanical abrasion
such as a wire brush.