For the following two problems, please use complete sentences in your description
1) (10) Why is the minimum number of teeth recommended on a gear with a 20 degree
pressure angle 14? (i.e. why is there a minimum, and what is undercutting?)
2) (10) What is the significance of the use of the involute curve in the gear teeth shape?
3) (26) Below is a schematic for a automatic transmission in an automobile, consisting of two
planetary gears. The arm of the first planetary gear is attached to the ring gear of the
second. The sun gear of the first planetary gear is also attached to the sun gear of the
second. The front view is for the first planetary gear. In first gear, the arm of the second
planetary gear is held motionless. The gears have number of teeth N,, Np and N, for the
sun, planet and ring gears respectively. What is the gear ratio in first gear?
ie
4) (27) Given the system shown, find an equation (or a set of simultaneous equations) from
which the necessary Tia which is generated by a motor between links 2 and 3, could be
found, given the link positions and their derivatives? Why is the motor not usually placed
here in most systems.
i sured at 3000 RPM. Size the driving
27) For a system, the following torque was mea:
reel 2 flywheel to obtain a coefficient of fluctuation of $%. (Hint, count boxes to
integrate)
Input Torque
TTT
Terque(tim)
180 360
Angie (deg)