Professional Documents
Culture Documents
SERVICE INFORMATION
If the Output Speed Sensor has been removed and replaced for any reason:
Output Speed
Sensor
CVT assy.
Figure 1
NOTE: Input/Turbine Speed Sensor does not require shims. That Sensor is flush
mounted to CVT casting.
The correct number of spacer shims must be installed between the Sensor and the CVT
body.
See the next page for shim number application chart.
Nissan Bulletins are intended for use by qualified technicians, not 'do-it-yourselfers'. Qualified technicians
are properly trained individuals who have the equipment, tools, safety instruction, and know-how to do a job
properly and safely. NOTE: If you believe that a described condition may apply to a particular vehicle, DO
NOT assume that it does. See your Nissan dealer to determine if this applies to your vehicle.
1/2
SERVICE PROCEDURE
1. Determine required number of shims by model:
Model Engine type Model Year Final gear ratio Required shim P/N
4. After determining the correct number of washers for the vehicle, place the shims over
the portion of the bolt that is exposed below the sensor body.
5. Assemble as seen below: Torque retaining bolt to 5.9 N•m (0.6 kg-m, 52 in-lb)
Shim location