Professional Documents
Culture Documents
MII 14565
INSTALLATION LIGHT BAR
CB500X/XA Issue Date
P/N 08P00-MGZ-J80ZC
INSTRUCTIONS May 2013
TORQUE CHART
Tighten all screws, bolts, and nuts to their specified
(1) (5) torque values. Refer to the Service Manual for the torque
(6)
values of the removed parts.
INSTALLATION
CAUTION
(10) • To prevent burns, allow the engine, exhaust system,
radiator, etc., to cool before installing the accessory.
(3) NOTE:
• Take care not to damage the painted surfaces of the
motorcycle.
(11)
1. Assemble the left light bar as shown.
• Repeat on the right side.
(8)
BOLT COLLAR
COLLAR BOLT
BOLT COLLAR
(Reuse) (Reuse)
COLLAR BOLT
(Reuse) (Reuse)
LEFT STAY
RIGHT STAY
2 of 4
6. Remove the bolts and nuts as shown. 8. Loosely install the right light bar as shown.
8 mm FLANGE NUT
RIGHT LIGHT BAR
BOLT
(Save) NUT
8 mm FLANGE BOLT
(long) 9. Loosely install the left light bar as shown.
RIGHT LIGHT BAR
NUT
LEFT LIGHT BAR (Reuse)
3 of 4
10. Loosely install the left light bar as shown. 12. Tighten all loosely installed hardware to the
specifications in the torque chart.
8 mm FLANGE NUT
LEFT LIGHT BAR
13. Install the left and right caps as shown.
• Repeat on the right side.
6 mm FLANGE NUT
6 mm FLANGE BOLT
4 of 4