Professional Documents
Culture Documents
1. Which of the following is not a type of Clutch? Wet Type, Semi Centrifugal, Diaphragm,
Release
2. Which type of bearing is installed at the end of the sleeve of a Release Brake ….. Ball Thrust
4. Four lines of small letters. Cap line, Waist line, Base Line. Drop Line
5. Narrower and spaced closer together Letters in drawing are known as. Compresses and
condensed
7. Types of Nuclear Power Plant and their cooling system. From R.K Jain
17. Allotropes are of only elements, not compounds, Oxygen and Carbon both have allotropes
22. Friction lining in a clutch, copper fibres, woven cotton/Kevlar fabric Asbestos etc.
24. In AC Current which of the following consumes power. Resistor, Inductor, Capacitor, All
25. In a release brake , drum brake axle requires ____ cylinder etc Double anchor Double
cylinder
26. Critical Damping is a function of which of the following, Mass and Stiffness
27. Which of the following Bevel Gears do the axis of rotation do not intersect but cross.Hypoid
29. All vibrating bodies have how many degree of freedom. 0,1,2,3
30.Tangent Modulus is defined as. Beyond the Yield Point stress to strain ratio
31. Extension of planes beyond their lines of intersection makes how many quadrants. 4
32. In which type of view is all geometry of the shape understandable in one view. Pictorial
35. In which type of view is perpendicular to one side of the geometry and inclined to two.
Auxiliary
39. Height of sea waves normally used for power generation. (2-3m)
44. Solar cells that adjust according to the sun and reflect light on a center receiver are known as.
Heliostat
47. In which cycle is air first compressed before inserting in the chamber. Brayton
49. Which powerplant operates at the highest speed? Petrol. Diesel. Steam. Hydro
50. Which line has precedence over all other lines? Full Line
53. Designs that satisfy the Independent Axium must have. Diagonal, Triangular, Rectangular.
Both (a) and (b)
59. Tool body that joins the lands on rotating tool is called. Web
60. Pulley in a belt acts as. Sliding Pair, Contact Pair, Higher Pair
65. In 1st angle of projection, top view is located in: Vertical, Horizontal, Auxiliary, Profile
Plane
68. Open Die forging operation in which thickness of bar is reduced by successive forging steps:
Choking,Cropping, Upsetting, Barreling, Cogging
69. Vibrating system is stable if. Amplitude not changing, Amplitude decreasing, Total energy
does not change
70. The theory postulates that failure will occur when the maximum strain due to the applied
stresses in a partequals the maximum strain at the yield point in uniaxial testing.
Maximum strain energy theory
71. Distortion Theory is also called: Van Hank, Le Stam, von Mises-Hencky theory
72. Ash content of coal can be reduced by: slow burning, washing, pulverizing
73. Uniform Scale Voltmeter: Hot wire, Induction, Moving Coil Permanent Magnet, Moving
Coil Dynamometer
74. Gas laws are applicable to: Gases and vapours, Gases and steam, Gases only not vapours,
Gases and vapoursat certain conditions.
75. Which powerplant has the lowest operation costs? Hydro, Nuclear, Petrol, Diesel
76. At node of the shaft: a) The vibrations are minimum b) The vibrations are maximum c) The
vibrations areaverage d) The vibrations are zero
77. Instantaneous value of Sinusoidal curve of AC current at 45 degree is. Peak, average, RMS,
peak to peak
78. Power in AC when voltage and current are out of phase by 90 degree. Zero