Professional Documents
Culture Documents
A set of standard codes define the display and behavior of the point components used in the AutoCAD
Civil 3D Corridor Modeling subassemblies.
The following illustration shows the location of the standard point codes on subassemblies defining a
divided road with a depressed median and truncated shoulders.
The table following the illustrations provides descriptions of the point codes used in the illustrated
assemblies.
The following illustration shows the location of the standard point codes on subassemblies defining a
divided road with a depressed median and extended shoulders:
6 ETW Edge of traveled way; inside or outside edges of travel lanes on finish grade.
16 EPS Edge of paved shoulder; outer edge of paved portions of shoulder on finish grade.
20 EPS_Sub Edge of paved shoulder; outer edge of paved portions of shoulder on the Subbase layer.
23 ES_Unpaved Edge of gravel shoulder; outer edge of unpaved portions of shoulder on finish grade.
24 Daylight_Sub Subgrade intercept point; point where the subbase surface extends and intersects the finish grade.
The following illustration shows the location of the standard point codes on subassemblies defining an
undivided road with a curb-and-gutter. Not all layers are shown.
The table below names and describes the standard point codes used in the example assembly
illustrations.
Point Codes
To view all actual code numbers, the code names and brief code descriptions: In Notepad, open
..\Documents and Settings\All Users\Application
Data\Autodesk\C3D2010\enu\C3DStockSubassemblyScripts.codes.