Professional Documents
Culture Documents
Who has the power to remove any member of the Board of Master Plumbers for neglect of
duty, incompetence, malpratice and unprofessional or dishonorable conduct?
A. President of the Philippines
B. Civil Service Commissioner
C. Commission on Appointments
D. Chairman of PRC Commissioner
2. What is the minimum pipe size of the standpipe if the highest outlet is located 23 meters or
less above the Fire Service connection?
A. 5 inches
B. 3 inches
C. 4 inches
D. 6 inches
3. What is the minimum number of approved slip joints fittings may be used on the putlet side
of the trap?
A. None
B. One
C. Three
D. Two
4. PD No. 1185 is another law that Master Plumbers used as their guide in the practice of the
plumbing profession. What is PD No. 1185?
A. Fire Code of the Philippines
B. Accessibility Law
C. Water Code of the Philippines
D. Code of Sanitation
5. For new, additional or altered plumbing installation not exceeding 20 units, the Building Code
stated that a Licensed Master Plumber could sign and affix his seal on the follpwing engineering
documents except
A. Isometric Drawing
B. Plumbing plan and layout
C. Design analysis and plans of the original installation
D. Guide specifications and bills of materials
6. Drainage piping serving fixtures located below the crown level of the main sewer shall
discharge into an approved water tight
A. Cesspool
B. Sump
C. Leaching Tank
D. Septic Tank
7. What is not needed to be installed when a combination standpipe system is installed in
accordance with the Fire Code?
A. Wet standpipe
B. Siamese connection
C. Sprinkler system
D. Dry standpipe
9. What is the shape for the signage for women's comfort room in order to aid visually impaired
women readilty determine whether a washroom is for men or women?
A. Circle
B. Rectangle
C. Square
D. Triangle
10. If the discharge of a fixture or drain may contain solids or semisolids heavier than water that
would be harmful to the drainage system or cause stoppage within the system, where the
discharge must pass first?
A. Screen wire mesh
B. Wooden baffle
C. Sand interceptor
13. What is the name of the professional organization for the Registered Master Plumbers here
in the Philippines?
14. What is the PRC Resolution Number is issued by the Board of Master Plumbing for the
adoption and promulgation of the Revised National Plumbing Code of the Philippines?
A. Res. No. 2
B. Res. No. 4
C. Res. No. 1378
D. Res. No. 962
15. Of the four board subjects given for Master Plumbers examination, which of this subject
was originally split into two subject?
A. Practical Problems
B. Plumbing Code
C. Plumbing Arithmetic
D. Design and Installations
16. Aside from Bell and Spigot, B & S in the code means
A. Butt and Soldered
B. Ball and Socket
C. Brown and Sharp
D. Browning and Smith
17. Building sewers shall be tested by completely filling the sewer with water from the ___
A. Lowest to at least ground level
B. Lowest to at least a 10-foot head
C. Lowest to at least a 5-foot head
D. Lowest to the highest point
18. The following are grounds for non-issuance of the certificate of registration by the Board of
Master Plumbers EXCEPT
A. Convicted by court for any criminal offense
B. Of unsound mind
C. Guilty of immoral or dishonorable conduct
D. Failure to pay the required fees
19. One of the Code of Ethics for Master Plumber states "Take advantage of a salaried ____
position to complete unfairly with a practicing Master Plumber." What is the missing word?
A. Competent
B. Government
C. Higher
D. Private
20. What Congress of the Republic of the Philippines approved after the third reading Rep. Act
1378 otherwise known as the Plumbing Law of the Philippines?
A. Sixth Congress
B. Fifth Congress
C. Second Congress
D. Third Congress
21. A type of drainage and venting system with universal branch line that is prohibited
A. Alternate
B. Single
C. Dual
D. Dependent
23.
24.
25.
26. According to the Fire Code of the Philippines what is the
required slope of all horizontal runs of dry standpipes system for
purpose of drawing?
27. Unless prohibited by structural conditions, what is the
reference of each vertical vent pipes before offsetting
horizontally to join the stack vent or vent stack?
29. What portion of the trap should the vent pipe opening will
not go below from a soil or waste pipe?
35. To allow cleaning of the soil and waste line each cleanout
should be installed
40. Aside from the number of fixture units connected to it, the
size of the vent piping is determined by its
41. For at least how many working days shall a required for
inspection of the plumbing works be filed before such inspection
be intended?
52. Except for plastic piping system, hot and cold water piping
may be tested with ___
64. In the water test of the entire plumbing system all openings
should be tightly closed except at
65. For the hot and cold water distribution system, on what side
should the hot water supply be placed in combination fittings?
68. A plumbing permit shall expire and become null and void if
the plumbing work authorized therein if not started for how
many days?
69. If a septic tank has a compartment that exceed 3.7 m in
length, what should be the additional requirement?
70. What is the minimum total net inlet area of roof deck drains
on roof deck used as sun decks and parking decks?
83. The Building Code stated that all dry standpipe outlets shall
be equipped with valves having substantial chains. What kind of
valve is this?
86. For how many days shall the Revised National Plumbing
Code will take effect following its complete publication in the
Official Gazette?
94.
98. Except on what fixture does the vent pipe opening from the
soil or waste pipe must not be below the weir of the trap?
103. Aside from galvanized steel, what is the other material for
dry standpipe that the Building Code allows?
105. According to Rep. Act 1378 for at least how many years
must the appointee to the Board of Master Plumbers must have
been actively engaged in the trade of plumbing?
107. What is the maximum length of the fire hose that shall be
equipped on wet standpipes?
108. Where practical, all pipes from fixtures shall be run in what
direction with respect to the nearest wall or building line?
110. Within how many days upon the approval of Rep. Act No.
1378 does it require to have a Board Examiners for Master
Plumbers formed?
112. Who shall set the criteria for the quality of drinking water
from meteoric, surface or underground sources?
113. Where should the overflow pipe lead for overhead tank
installed on buildings?