Professional Documents
Culture Documents
The coefficient
of friction between all tires and the road is 0.80. How fast 35. A single force (not shown) is applied at point B in the y-
can the car and trailer travel around an unbanked curve of direction, in line with points A and B. What should this
radius 200 m without either the car or trailer skidding? force bein order for the frame to be in equilibrium in that
Select one: direction?.
a. 143 km/h
b. 75.2 km/h
c. 40.0 km/h
d. 108.1 km/h
Select one:
a. 3.23 m
b. 10.1 m Select one:
c. 4.78 m a. 2.5 m/s
d. 7.78 m b. 0 m/s
c. 1.4 m/s
d. 5.6 m/s
Select one:
a. w/3
b. w/4
c. 4w/7
d. 4w/7
Select one:
a. TA /= 699 N ; TB /= 699 N ; TC /= 1398 N
b. TA /=1398 N ; TB /= 1398 N ; TC /= 0 N
Select one: c. TA /
a. 80 N d. TA /= 1398 N ; TB /= 0 N ; TC /= 1398 N
b. 60 N
c. 50 N e. TA = 699 N ; TB = 1398 N ; TC = 699 N
104. A box has uniform density and a total weight of 600
N. It is suspended by three equal-length cables, AE,BE, and
97. Three coplanar forces are in equilibrium on the surface
CE, as shown. Point E is 0.5 m directly above the center of
of a steel plate, as shown. Two of the forces are known to
the box's top surface. What is the tension in cable CE?
be 10 N. What is the angle, , of the third force?
Select one:
Select one: a. 400 N
a. 82.5o b. 200 N
b. 26.7o c. 128 N
c. 53.8o d. 370 N
d. 7.50o
Select one: 109. A model T-beam is constructed from five balsa
98. A signal arm carries two traffic signals and a sign, as
a. 5.65 m2 boards. Refer to the illustration for the as-built
shown. The siognals and sign are rigidly attached to the
b. 1.15 m2 dimensions. What is the approximate centroidal moment
arm. Each traffic signal is 0.2 m2 in frontal area and weighs
c. 8.03 m2 of inertia about an axis parallel to the -axis?
210 N. The sign weighs 60 N/m2. The design wind pressure
d. 1.04 m2
is 575 N/m2. The maximum moment that the connection
between the arm and pole can withstand due to wind is
6000 N m , and the maximum permitted moment due to 102. QUEST032::Figure shows a uniform disk, with mass M
the loads is 4000 N m. As limited by moment on the = 2.5 kg and radius R = 20 cm, mounted on a fixed
connection, what is the maximum area of the sign? horizontal axle. A block with mass m = 1.2 kg hangs from a
massless cord that is wrapped around the rim of the disk.
Find the acceleration of the falling block. The cord does
not slip, and there is no friction at the axle.
Select one:
a. -4.8 m/s2
b. 4.8 m/s2
c. -3.2 m/s2
d. 3.2 m/s2
Select one:
a. 660 cm4
b. 600 cm4 a. 1.0 rad/s
c. 500 cm4 b. 1.4 rad/s
d. 560 cm4 140. An isolated parallel-plate capacitor (not connected to c. 1.2 rad/s
a battery) has a charge of Q = 2.9 × 10-5 C. The separation d. 2.0 rad/s
110. A 3 kg disk with a diameter of 0.6 m is rigidly attached between the plates initially is d = 1.2 mm, and for this
at point B to 1 kg rod 1 m in length. The rod-disk separation the capacitance is 3.1 × 10-11 F. Calculate the
combination rotates around point A. What is the mass
moment of inertia about A for the combinanation work that must be done to pull the plates apart until their
separation becomes 5.3 mm, if the charge on the plates
remains constant. The capacitor plates are in a vacuum
Select one:
a. 5 J
b. 46 J
c. 48 J
d. 47 J