Professional Documents
Culture Documents
KENWOOD TH-F6A
Programming a Frequency (Simplex) or a Repeater
1. Press A/B and select band A
2. Press the VFO key
3. Press the ENT key
4. You can enter your desired frequency in either of three ways.
a. Using the keypad enter the frequency (the radio will enter the decimal point for you).
b. Press the BAND/2 key to the desired band. Use the joy stick, ▲/▼ to choose the
frequency.
c. Press the BAND/2 key to the desired band then turn the tuning knob to the desired
frequency.
If you find you cannot tune the last two digits of the frequency because the dial or the ▲/▼ goes
past the frequency you will have to change the frequency step to a finer setting. Refer to
Changing the Frequency Step below.
You do not need to go further for a simplex frequency. However, remember the offset and PL
need not be set.
5. Select the offset. First press the F key. Then press the REV/SHIFT/8 key. Every time the F and
REV keys are pressed the display will change from + to ─ to no sign for a simplex frequency.
6. Select the TONE/ENCODE/PL. Press the TONE/TSEL/7 key. A T will now appear in the display.
7. Now, select the PL/TONE by pressing the F key. Then press T.SEL/TONE/7. The display will now
show TONE FREQ with a tone frequency flashing. Turn the main tuning knob to the desired
PL/TONE frequency you want. Store this tone by pushing the MENU joystick to the right. The
display will show OK to store.
Information Channels
1. Press INFO to recall the information channels.
2. Information channels appear on the B band.
FM
1. Go to Band B.
2. Press the BAND key until 51.000 MHz is displayed. Now go to the next frequency bank shown on
the display.
3. Enter the desired frequency (example 102.7 FM).
4. Press the ENT key. Enter 102.
5. Press the MHz key for the decimal point.
6. Enter 700 from the key pad.
7. Press the F key.
8. Press the BAND/MODE key. Select WFM.
9. Turn off the Squelch. Press SQL.
10. Turn main tuning knob to the left so no vertical bars are showing.
11. Press SQL to exit this mode.
Scanning
SCANNING A BAND
1. Press VFO.
2. Press BAND to select desired band to scan.
3. Press VFO and hold for one second. This starts the band scan.
4. Press VFO or PTT to stop the scan.
Transmit Power
Press LOW. Each time you press LOW the radio cycles between the three power levels.
H (HIGH) – 5W Power levels differ for the different batteries. These
L (LOW) – 0.5W levels are for the standard PB-42L battery.
EL (Extra LOW) – 0.05W
The Th-F6A is equipped with a transceiver, for the A band, and a receiver, for the B band.
This allows you the capability of monitoring two frequencies at the same time.