TEST REPORT SABS
High Voltage Laboratory
Report No. HV/105640
Page 1 of 5
Client + Diamond Power infrastructure Limited
Essen House, 5/12,B.|.D.C, Gorwa, Vadodara - 390016
Manufacturer : Diamond Power infrastructure Limited, India
‘Apparatus tested ACSR Bersimis conductor (Al 42/4.57 +St 7/2.54 mm)
Voltage rating 2765 kV
Configuration type + Quad bundle
Bundle Spacing 2457 mm
Sample Identification + No Identifeation
Tests performed + Dry RIV and Corona tests.
‘Tests have been carried out in accordance with the client's instructions:
Test procedures and test parameters were based on:
Radio Interference characteristics of overhead power lines and high-voltage:
C.LS.P.R. Publication 18-2: 2010 equipment Part 2: Methods of measurement and procedure for determining
limits
Clause 4.6.13 Test procedure
Date of tests +: 24 May 2011
Conclusion
+ The results are shown in section 4 of this report
This report consists of the following pages:
Report forms 5
Ah
hide /den Heover é
tng ee ay Lobe
NETFA oe. ES
GW Bourn (Technical Signatory)
Specialist: High Voltage Laboratory
NETFA
Olifantsfontein, 10 June 2011,
1 Apollo Road, Olifantsforitein, P.O.Box 144, Olifantsfontoin, Tol: +27 (011) 238 2300, Fax: +27 (014) 238 2363
‘The est wor lating oh report was peroned by SABS Commercial (Py) Lid. Th rept ais el resus teeny othe spec
pat) ere he. hay ra ingly SASS deport he sual uclr fener ate ans aweeiorans eee we ASA
‘ere re one to any snr hom tutus tt Sas ned cr Bed te oats ie son ARES ==
‘hs rpm nyt priced arcana Th stant of pa anh cons ans Ce oy cntcing eased CaS»‘South African Bureau of Standards
TEST REPORT No. HV/105640 Page 2 of 5
1
Test method
‘The four Bersimis conductors comprising the quad bundle were cut to 6m lengths and provided
with crimped dead-ends.
The conductors were then attached to end plates with 457mm spacing between conductors.
‘The bundle conductor was provided with discharge-free terminations and suspended at a height
of 15 m (geometric mean centre to grounc)
Photographs of the suspended test sample and environment are shown in photographs 1 and 2
below.
Photograph 1
Test object suspended
at 15m,
Photograph 2 Test object viewed from belowSouth African Bureau of Standards
‘TEST REPORT No, HV/105640
age 3018
2 Measuring equipment
The following equipment was used for the measurements:
Marcondmodet | A85 numver MPRIER OA] carey
a TEST
i peak votre’ —— [Pano Type sae5 861 | Nort $108
Sd ioe
Hon
Fenowonr vis 7400 sosenses | oan Hos
Shoe
CGallbraton of the above equipment ls kaceable to national standards.
2.1 Tolerance on measurements
AC voltage 2%
RIV 5%
3 Test conditions
The tests were conducted at the National Electrical Test Facility of the South African Bureau of
Standards.
Test laboratory altitude: 1540 m
‘Sample condition: The sample arrived wrapped in a protective cover which was removed
after the sample was strung up for testing.
4 Results
41. RIV and visible corona measurements,
Table 1 on the next page shaws the sequence of voltage application and the results of RIV and
visible corona tests.
The plot of all recorded RIV values is shown in Figure 4
2a May 71
RIV
|
80
70
60
tm 50
3 40
30 a
20 *
10
0
400-420-440, 460480 500-520 540880
KV (measures)
‘SARS /NETFA
Figure 1, Plot of RIV against applied voltage
Sample ACSR Bersimis conductor (Al 42/4 57 +St 7/2.54 mm)
Manufacturer: Diamond Power Infrastructure LimitedSouth African Bureau of Standards
TEST REPORT No, HV/105640 Page 4of5
Pressure 85_|kPa Temperature 7 |e
Humidity 7.09 |g/m* Height (GMR) 15__|m
Atmospheric correction factor: 0.87
Specified Test voltage Up 510 |kv
Voltage e RIV
3
iat measured | corrected” | § (Mnz; 3000)
E | increasing votage | decreasing voltage
kV kV sel a ww. aB wv
106% 540 667 5 | 80 | 10000 | 80 | 10000
100% 510 630 58 | 704 | 58 | 704
106% 540 667 1 80 10000
530 654 69 | 2818
520 642 66 1995
515 636 64 | 1585
510 630 58 794
505, 623 54 501
500 6i7 52 | 398
490 605 36 63
450 556 30 32
425 525 27 22
400 494 26 18
0 o 25 | 18
oO oO 25 18
° 0 25 | 18
oO oO 25 18
oO oO 25 18
‘c Inception Extinction
£
é reading | mean| corrected reading mean | corrected
3 kv. kv kV. kV. kV. kv
g 517 512
g 514 515 636 511 512 | 632
oO
515 513
“oprrected to 20°C, 101 3kPa and 1 g/m’ humidity in accordance with IS 731-1971 Appendix A
Table 1. ‘Sequence of voltage application and measurements of RIV and corona‘South African Bureau of Standards
TEST REPORT No. HV/105640 Page 5 of §
Ina further test, the visible corona inception and extinction voltages (as viewed through a corona
camera) were determined 3 times. The photographs below show the corona at the highest
uncorrected voltage and at the required uncorrected corona-free voltage.
bor LO Meurer lire)
44.1 Summary of Corona tests
Parameter Measured Corrected™
Corona inception (mean of )[__ 515 KV. 636 KV
Corona extinction (mean of 3) _512__—iKV 632K
“ToS. 731-1971 Ea. 38)
441.2 Summary of RIV tests
‘Applied voltage RV Gy)
Measured [ corrected” | frequency measured
‘510 KV 630_KV 7.0__MHz | 58 oB 798
“eis 731-1971 Ed 38)