Professional Documents
Culture Documents
DATA SHEET
Applications:
● CCD Camera
● Night Vision
● Infrared applied system
Super Bright LEDs, Inc.
Package Dimensions
IR-1WS-850
IR-1W-850
IF=350mA 10 30 --
Radiant Intensity IE mW/sr
IF=700mA 30 60 --
Peak Wavelength λp IF=20mA -- 850 -- nm
Spectral Bandwidth Δλ IF=20mA -- 50 -- nm
IF=350mA 1.0 1.6 2.5
Forward Voltage VF V
IF=700mA 1.2 1.9 3.0
900 100
IF=20mA
800 Ta=25° C
Rthj-L=45°/W
700 80
600
60
500
400 40
300
20
200
100
0
0 20 40 60 80 100 120 790 810 830 850 870 890 910 930 950
900 3.0
2.8
2.6
875
2.4
2.2
850 2.0
1.8
1.6
825 1.4
1.2
800 1.0
-25 0 25 50 75 100 0 100 300 500 700 900 1000
Super Bright LEDs, Inc.
0 10
1.0
20
30
0.8
40
50
0.6
60
Relative Intensity
0.4
70
0.2 80
0.0
-90 -80 -70 -60 -50 -40 -30 -20 -10 0
90
Angle (Degree)
Super Bright LEDs, Inc.
2.Special thermal designs are also recommended to take in outer heat sink design, such as FR4
PCB on Aluminum with thermal vias or FPC on Aluminum with thermal conductive adhesive,
etc.
3.Sufficient thermal management must be conducted, or the die junction temperature will be
over the limit under large electronic driving and LED lifetime will decrease critically.
Super Bright LEDs, Inc.
Handling Indications:Do not handle the IR by the lens at any time during the
assembly process. This can cause damage to the optical surfaces or may dislocate the lens if
excessive force is applied.
Super Bright LEDs, Inc.
4. Soldering Iron
1.For prototype builds or small series production runs it is possible to place and solder the LED by hand.
2.Dispensing thermal conductive glue or grease on the substrates and follow its curing spec. Press
LED housing to closely connect LED and substrate.
3.It is recommended to hand solder the leads with a solder tip temperature of 280°C for less than 3 seconds
within once in less than the soldering iron capacity 25W. Leave two seconds and more intervals, and do
soldering of each terminal.
4.Be careful because the damage of the product is often started at the time of the hand solder.