Professional Documents
Culture Documents
Part I: Intro
Using Autodesk Inventor
Level: Introduction
0. OUTLINE
a. Startup
3/24/2014 Inventor - Assembly Model Intro -jcS
New
c. Adjust Display
3/24/2014 Inventor - Assembly Model Intro -jcS
Save
Workspace:
d. Save
3/24/2014 Inventor - Assembly Model Intro -jcS
2. FIRST COMPONENT
a. Place Component
3/24/2014 Inventor - Assembly Model Intro -jcS
Grounded:
oPart XYZ planes match Assembly XYZ planes
Move the part:
Pick: FirstDemo.ipt
Drag (Hold <LMB>): Move Cursor
• No motion
b. Location
3/24/2014 Inventor - Assembly Model Intro -jcS
Remove Ground
<RMB> FirstDemo.ipt
Pick: Grounded
Verify change:
• Before:
• After:
Move the part
Pick: the component
Drag: Free to move
c. Position
3/24/2014 Inventor - Assembly Model Intro -jcS
Assemble:
Constrain
Selection 1: Front Face
Selection 2: XZ Plane Before:
Flush
Select: Apply | Close
After:
d. Reorient(first Constraint)
3/24/2014 Inventor - Assembly Model Intro -jcS
Verify
View: the component
Drag:
After:
Verify
View:
Drag:
After:
After:
a. Location
3/24/2014 Inventor - Assembly Model Intro -jcS
Appearance:
Pick: Component
Pick: As Material
Pick: Blue
b. Color
3/24/2014 Inventor - Assembly Model Intro -jcS
Reference Planes
Select:<Ctrl>+<lmb>
Visibility
c. Adjust Display
3/24/2014 Inventor - Assembly Model Intro -jcS
Rotate Component
Pick: Component
<RMB>
Pick: Component
Pick: Free Rotate
Drag: Component
d. Orient
3/24/2014 Inventor - Assembly Model Intro -jcS
Align edges
Assemble:
Constrain
Selection 1: Edge
Selection 2: Edge
Mate
Before:
After:
e. Orient(first Constraint)
3/24/2014 Inventor - Assembly Model Intro -jcS
Verify
View:
Drag:
After:
3. PRACTICE
a. Additional components
3/24/2014 Inventor - Assembly Model Intro -jcS
4. FINISH