i yellow = Water separator in fuel pre- cleaner. Lights when the water proportion in the fuel filter reaches the contacts. j red = N/A k yellow = Glow Plugs indicator lights when temperature is low (pre-heating for starting) l red = Hazard light*, flashes when the hazard light is activated.
Fig. 8 m = Operating hour meter, counts
the operating hours while No. 2 = Instrument cluster the engine is running. All maintenance work must be NOTE: With the ignition switch in position I all performed according to the gauges and instruments are switched on indicated operating hours. for 3 seconds. n = Fuel tank filling level. a red = flashes when the engine overheats, the warning buzzer sounds, the engine is shut down after 2 minutes. Switch No. 3 = Vents for air conditioning, heating off vibration, run engine and ventilation, driver* with idle speed or shut down No. 4 = Vents for air conditioning, heating engine if necessary, clean and ventilation, footwell* engine oil cooler and radiator, if necessary repair engine. b red = flashes if engine oil pressure too low, engine is shut down after 10 seconds. Check engine oil level, repair the engine if necessary. c yellow = N/A d yellow = Charge control light, lights if battery is not being charged. Check V-belt, if necessary repair the generator. e yellow = lights if the hydraulic oil filter is contaminated, the engine is shut down after 2 minutes. Check hydraulic system, replace hydraulic oil filter. f yellow = N/A g red = Parking brake, with lever shifted to parking brake position, with driver’s seat unoccupied. h green = Direction indicator*, flashes when the direction indicator switch is actuated.