Professional Documents
Culture Documents
a. Gas convection
b. Conduction
c. Wall radiation
d. Gas radiation
a. 1
b. 25
c. 100
d. 50
5. If the tube wall thickness is negligible, whether the approximation of h = hi = ho for the convection
heat transfer coefficient in a heat exchanger is reasonable?
Select one:
a. No.
b. Yes.
c. Probably yes.
b. Exit temperature of the hot fluid can never be higher the cold fluid exit temperature
c. Exit temperature of the hot fluid never be accounted for design of heat exchanger
d. Exit temperature of the hot fluid can never be below the cold fluid exit temperature
In Parallel flow heat exchangers, the outlet temperature of the "cold" fluid can never exceed the outlet
temperature of the "hot" fluid.
a. Hydraulic motors
b. Non-induction motors
c. Induction motors
d. Electric motors
9. Percent of initial light output from lamps decreases with time due to
Select one:
a. Lack of maintenance
b. Environment conditions
c. Dirt depositions
10. Latent heat of condensation of water in the combustion products is included into the
Select one:
a. Surface density
b. Area density
c. Pressure density
d. Volume density
a. 10
b. 8.5
c. 9.5
d. 9
15. From the following, identify the suitable type of furnace used for calcination process:
Select one:
c. Rotary Kiln
d. Sintering furnace
16. Losses due to radiation for a fully adiabatic boiler for a wind velocity of 10 km per hour is
Select one:
17. For specified inlet and outlet temperatures, for what kind of heat exchanger will the LMTD be
greatest?
Select one:
18. In heat exchangers, the effects due to thermal and structural stresses are normally not considered
at
Select one:
19. The temperature rise of the cold fluid in a heat exchanger will be equal to the temperature drop of
the hot fluid, when the
Select one:
b. Heat capacity rates of the cold and hot fluids are identical
d. Temperature of hot fluid is much greater than that of the cold fluid
b. Fuel characteristics
c. Thermal insulation
d. Heat loss factors
c. Ensure the utilization of lamps and bulbs to their fullest possible extent
22. Heat exchangers for airplanes should preferably be selected based on their
Select one:
24. The increase in the system resistance for a fluid flowing through a pipe or duct leads to
Select one: