No. (a) The exposed surfaces of nick break specimen shall show API 1104 Para complete penetration & fusion. Nick Break Test Refer Table in (b) The greatest dimension of any gas pocket shall not 5.6.3.3 Page 4 of 4 exceed 1.6mm and the combined area of all gas pockets shall not exceed 2% of the exposed surface area. (c) Slag inclusion shall not be more than 0.8mm in depth and shall not be more than 3mm or one half the specified wall thickness in length whichever is smaller. 3 (d) There shall be at least 13mm separation between adjacent slag inclusions of any size. Note: For Weld diameter greater than 12.75 inch, if only one nick break specimen fais, then the specimen may be replaced by two additional nick break specimens from locations near to the failed specimen. If the either of the replacement fail, the weld is considered unacceptable.
(a) The bend test shall be considered acceptable if no crack
or other imperfections exceeding 3.0 mm or one half the specified wall thickness whichever is smaller. (b) Cracks that originate on the outer radius of the bend along the edges of the specimen during testing and that are less than 6.0 mm measured in any direction shall not be considered. Sleeve & Branch : Root API 1104 Para 5.6.4.3 & 5.6.5.3 Refer Table in (c) The Sleeve or Branch Weld reinforcement is removed 3 Face Bend /Root Page 4 of 4 flush the surface of the test specimen. The specimens in Bend /Side Bend the other direction are not flattened prior to testing. Where the wall thickness is greater than 12.7mm it may be reduced to 12.7mm by machining the inside surface. Note: The Face Bend Specimens should not be tested less than 24 Hrs. after welding.