Professional Documents
Culture Documents
INSTRUCTION MANUAL
A Complete Lineup of In-Stock Lathe Tooling for Okuma Two Year Warranty
VELOCITY/SU-MATIC INSTRUCTION MANUAL
1
V E L O C IT Y P R O D U C T S .C O M
2
V E L O C IT Y P R O D U C T S .C O M
2) Place the tool in the turret station two positions above the
machining station and install tool mounting bolts - do not tighten
mounting bolts yet.
3XVKWRROIURPWKHIURQWWRÀUPO\SRVLWLRQWKHIURQWUHIHUHQFH
plate against the front of the turret face.
4) Firmly tighten the back mounting plate at the rear of the tool
against the back face of the turret.
3
V E L O C IT Y P R O D U C T S .C O M
LT2000 driven tools are pre-set at the factory to align the tool
output with the Z-Axis.
Screw n Screw o
Alignment Do Not
Bearing Pocket Move This
Screw
Do Not
Move This Alignment
Screw Bearing Pocket
Screw o Screw n
1) Place the tool in the turret station three positions above the
machining station.
4
V E L O C IT Y P R O D U C T S .C O M
1,450 PSI high pressure axial internal 1,450 PSI high pressure axial internal
coolant tool with switch on back coolant tool with switch on front
* )DLOXUHWRXVHFRRODQWÀOWUDWLRQDQGLQWHUQDOFRRODQWDVGHVFULEHGDERYHYRLGVWKHWRROZDUUDQW\
5
V E L O C IT Y P R O D U C T S .C O M
6
V E L O C IT Y P R O D U C T S .C O M
7
V E L O C IT Y P R O D U C T S .C O M
Use torque
wrench to
install
Capto
cutting unit.
Torque specification
is shown on tool.
8
V E L O C IT Y P R O D U C T S .C O M
LEFT LEFT
10
INSTRUCTION MANUAL
A Complete Lineup of In-Stock Lathe Tooling for Okuma Two Year Warranty*
Velocity Products 350 Electronics Blvd, Huntsville, AL 35824 256-258-5549
www.velocityproducts.com sales@velocityproducts.com
*Warranty voided if internal coolant tools are used without coolant and coolant filtration.
Exceeding specified maximum cutting tool sizes voids warranty.
© Velocity Products Specifications subject to change without notice SU-matic Instructions 10.2016