Professional Documents
Culture Documents
Q.3 What is the partial safety factor for dead load when it contributes to the
stability of the structure against overturning? 1
(a) 1
(b) 1.5
(c) 1.2
(d) 0.9
Q.5 What is the minimum pitch distance according to IS 800:2007 if d is the bolt diameter?
1
(a) 2d
(b) d
(c) 1.7d
(d) 2.5d
Q.7 What is the maximum distance between two consecutive bolts (in tension) if the
plate thickness is 10 mm? 2
(a) 160 mm
(b) 200 mm
(c) 250 mm
(d) 180 mm
Q.8 What is the design wind pressure if the design wind speed is 50 m/s2? 2
(a) 1.5 kN/m2
(b) 1.8 kN/m2
(c) 2 kN/m2
(d) 1 kN/m2
Q.9 IS: 800-2007 limits the values of width-to-thickness ratios of the elements
of a steel section to place a check on 1
(a) bending buckling
(b) torsional buckling
(c) flexural-torsional buckling
(d) local buckling
Q.10 The necking of the steel section during tensile test takes place 1
(a) at yield stress
(b) in strain hardening range
(c) after reaching ultimate tensile stress
(d) at plastic yielding
Q.11 Partial safety factor for material resistance governed by ultimate stress is
taken in IS 800:2007 as 1
a) 1.25
b) 1.2
c) 1.5
d) 1.10
Q.12 Partial safety factor for resistance of field fabricated welds is taken in
IS 800:2007 as 1
a) 1.25
b) 1.2
c) 1.5
d) 1.10
Q.13 The partial safety factor for DL + LL + CL in limit state of strength is taken as 0
a) 0.9
b) 1.2
c) 1.5
d) 2
Q.14 According IS 875 (part-3) 1987 the numbers of zone are 1
e) 3
f) 4
g) 5
h) 6
Q.15 The mechanical properties of steel largely depend on its 1
a) Chemical composition
b) Heat treatment
c) Rolling method
d) All the above
Q.16 The minimum edge distance in member with rolled edge (for bolted connection) is
approximately 1
a) 1.5 × bolt diameter
b) 1.5 × hole diameter
c) 1.7 × bolt diameter
d) 1.7 × hole diameter