Professional Documents
Culture Documents
22
Release Notes
This document contains important information about the Unity Pro PlantStruxure
DTM Library software component. Please read the complete document before you
start the installation and operation of the product.
1. Overview
Unity Pro PlantStruxure DTM Library V1.1.22 contains the following Master DTMs and
Generic DTMs
3. System Requirements
4. Installation
In order to install Unity Pro PlantStruxure DTM Library software component, you
must have administrative privileges.
You can re-run the installer from the Add/Remove Programs Control Panel.
If you have already installed Unity Pro PlantStruxure DTM Library, the installer gives
you options to Modify, Remove or Remove Unity Pro PlantStruxure DTM Library.
Note: To Modify or Repair, Unity Pro PlantStruxure DTM Library installer should be
available.
6. Known Issues
7. Troubleshoot
Step 1: In the main menu, select Tools -> Project Settings... The Project Settings
window opens.
Step 4: Click OK to save your changes and close the Project Setting window.
After the Upload information setting is disabled, you can build the application
and download it to the PLC.
(a) a version of Unity Pro that is equal to or higher than the version used to
create the application
(b) the master DTMs for the modules included in the configuration
(c) the DTMs for all DTM-based devices attached to the network (the DTMs must
be of the same or higher revision as each device DTM used in the configuration)
(d) the EDS files for any EtherNet/IP device used in the configuration (the EDS
files must be of the same or higher revision as each device EDS file used in
the configuration)
After all the above components have been installed on the target PC, you can
upload a DTM-based Unity Pro application from a PLC.
http://www.wireshark.org/
Install this tool with the associated WinPcap promiscuous mode driver and
collect the packet capture as instructed by your Schneider Electric Customer
Support Representative.