You are on page 1of 5

CI RCUITOS RECTIFICADOR DE ONDA

COMPLETA CON FILTRO POR


CAPACIDAD
Jose Luis Coronación Sedano
Facultad de Ingeniería Eléctrica y Electrónica, Universidad Nacional de Ingeniería
2018 Lima, Perú

Abstract

Check that with the use of a filter in a rectifier


the content of the alternating component
decreases and a continia component with a
voltage ripple is obtained that is checked with
the equations.

I. FUNDAMENTO TEÓRICO

A. FULL WAVE RECTIFIER WITH


CAPACITIVE FILTER

The operation of this circuit is entirely


similar to that of a half wave, with the only
difference that the exponential decay (or its
linear approximation) meets the rectified
negative peak, instead of the next positive
peak.

2.410
𝑟=
4√3𝑓𝑅𝐶
R en k ohm,C en micro Faradios

1
B. Simulation

2
3
The maximum current in the capacitor
is given because the capacitor at the

start is discharged so that a current is


C. Questions triggered that then lowers and
remains, the case of 47u the peak
How much is the maximum inverse current was 215mA and in the case of
voltage that supports the diodes? 500u the current was of 2.25A

What correspondence is there


The reverse voltage that the diodes between the current of a diode and
have to withstand is half of what the the load?
diodes have to support in a full wave
rectifier with 2 diodes, which reduces is in relation to 1 to 1 because the total
the cost of the circuit, then the current is divided by 2 by the number of
reverse voltage of break is the diodes and the peak currents are going to
maximum voltage in reverse direction the capacitor
that a diode can support without
entering into driving; This voltage for
a rectifier diode is destructive, so
when designing a circuit always use a
safety factor that is not determined,
but depends on the designer.

How much is the pixel current in the


capacitor?

4
5

You might also like