Professional Documents
Culture Documents
COL
TX
RX
werantwortlich ist.
Attention !
ON = OK
Ceci est un produit de Classe A. Dans un environment domestique, ce produit risque de créer des
interférences radioélectriques, il appartiendra alors à l’utilsateur de prende les measures spécifiques
appropriées
STATUS
E-FRL-MC05 E-FRL-MC05(SM)
Provides an AUI connector and a set of Provides an AUI connector and a set of
RX (receive) and TX (transmit) ST RX (receive) and TX (transmit) ST
connectors to 10BASE-FL 850nm connectors to 10BASE-FL 1300nm
multimode fiber. singlemode fiber.
E-FRL-MC05(SC)
CAUTION: RJ connectors are NOT INTENDED FOR CONNECTION TO THE Provides an AUI connector and an RX
PUBLIC TELEPHONE NETWORK. Failure to observe this caution could result in (receive) /TX (transmit) SC connector to
damage to the public telephone network. 10BASE-FL 850nm multimode fiber.
Der Anschluss dieses Gerätes an ein öffentlickes Telekommunikationsnetz in den EG-Mitgliedstaaten
verstösst gegen die jeweligen einzelstaatlichen Gesetze zur Anwendung der Richtlinie 91/263/EWG zur
Angleichung der Rechtsvorschriften der Mitgliedstaaten über Telekommunikationsendeinrichtungen
einschliesslich der gegenseitigen Anerkennung ihrer Konformität. The E-FRL-MC05 functions either in
half-duplex mode or in full-duplex E-FRL-MC05 in the Network . . . . . . .2
Trademark Notice Installation . . . . . . . . . . . . . . . . . . . .3
All registered trademarks and trademarks are the property of their respective owners. mode, depending upon the network
devices to which the media converter is Operation . . . . . . . . . . . . . . . . . . . . .4
Copyright Restrictions
attached. Fault Isolation and Correction . . . . .5
© 1999, 2001 TRANSITION Networks.
All rights reserved. No part of this work may be reproduced or used in any form or by any means – Cable Specifications . . . . . . . . . . . . .6
graphic, electronic, or mechanical – without written permission from TRANSITION Networks. Technical Specifications . . . . . . . . . .7
Printed in the U.S.A. 33117.B Compliance Information . . . . . . . . . .8
E-FRL-MC05 IN THE NETWORK TECHNICAL SPECIFICATIONS
NOTE: AUI drop cable also can be used to connect to the transceiver. Standards IEEE 802.3
Case Dimensions 3.8 x 1.65 x .94 inches (95 x 42 x 24 mm)
Weight 3.5 oz. (99.2 g)
10BASE-FL Hub
Environment Temperature: 0-40°C (32° to 104° F )
Humidity 10-90%, non condensing
Altitude 0-10,000 feet
Power 11.4 - 16.5 VDC,
OR SQE = ON 175 mA (typical), 300 mA (maximum)
STATUS
Warranty Lifetime
ON = OK
COL
RX
TX
OR
SQE = ON
COL
TX
RX
ON = OK
STATUS
SQE = OFF
Hub with AUI connector
COL
TX
RX
ON = OK
DECLARATION OF CONFORMITY
STATUS