Professional Documents
Culture Documents
VERSION 1
INSTALLATION AMBIENT LIGHTS 2016 FIT
Issue Date
INSTRUCTIONS P/N 08E10-T5A-100
MAR 2015
8 Wire ties
Fuse label
© 2015 American Honda Motor Co., Inc. – All Rights Reserved. 01671-01 08E10-T5A-1000-90 1 of 7
INSTALLATION 3. Open the glove box, push inward on the stops, and
remove the glove box.
Customer Information: The information in this
installation instruction is intended for use only by skilled SCRIBE MARK
(Align with
technicians who have the proper tools, equipment, and PROJECTION projection.)
training to correctly and safely add equipment to your
vehicle. These procedures should not be attempted by
“do-it-yourselfers.”
2 CLIPS
Push.
Push.
PASSENGER’S 4. Pull back the door opening seal, and remove the
UNDER COVER 2 PINS
driver’s dashboard side lid.
QC90301AJ
DRIVER’S 5 RETAINING
DASHBOARD QC71818AJ
TABS
SIDE LID
2 of 7 01671-01 © 2015 American Honda Motor Co., Inc. – All Rights Reserved.
5. Remove the driver’s dashboard lower cover, and 7. Remove the center lower cover, and unplug the
unplug the vehicle connectors. vehicle connectors.
4 RETAINING
TABS
4 CLIPS
BOLT
4 RETAINING TABS
(Access from the
DRIVER’S glove box opening.)
DASHBOARD QC71819AJ CENTER LOWER QC83102AH
LOWER COVER COVER
6. Apply tape to the areas shown. 8. Using isopropyl alcohol on a shop towel, thoroughly
clean the area where the fuse label will attach.
SHIFT LEVER
(“D” position) TAPE DASHBOARD
FUSE CASE
(Clean with
isopropyl
alcohol.)
FUSE LABEL
(2A FOOT LIGHT
(ILLUMI+))
AMBIENT
LIGHT
HARNESS
QC83101AH QC90303AJ
CENTER LOWER
COVER CENTER
CONSOLE 9. Attach the fuse label to the ambient light harness
fuse case.
© 2015 American Honda Motor Co., Inc. – All Rights Reserved. 01671-01 3 of 7
10. Unplug the vehicle 14-pin connector, and plug it into 12. Route the ambient light harness as shown. Then
the ambient light harness 14-pin connector. Plug the loosely secure the ambient light harness to the
ambient light harness 14-pin connector into the vehicle harness with one wire tie.
vehicle 14-pin connector.
WIRE TIE
(Loosely secure.)
VEHICLE HARNESS AMBIENT LIGHT
14-PIN CONNECTORS HARNESS
14-PIN
CONNECTORS
BRACKET
SELF-TAPPING DRIVER’S
SCREW DASHBOARD
LOWER COVER
VEHICLE GREEN QC90305AJ
CLIP QC90402AJ
TAPE
WIRE VEHICLE AMBIENT LIGHT
TIE HARNESS HARNESS
4 of 7 01671-01 © 2015 American Honda Motor Co., Inc. – All Rights Reserved.
14. Install the ambient light to the bracket with one self- 16. Secure the ambient light harness to the vehicle
tapping screw. harness with two wire ties. If other accessory
harness is already secured to the vehicle harness,
secure the ambient light harness to other accessory
harness with two wire ties. Tighten the wire tie.
AMBIENT
LIGHT
DRIVER’S
DASHBOARD
LOWER COVER
2 WIRE AMBIENT QC90405BJ
2 WIRE AMBIENT TIES
TIES LIGHT LIGHT
HARNESS HARNESS
WIRE TIE
© 2015 American Honda Motor Co., Inc. – All Rights Reserved. 01671-01 5 of 7
18. Route the ambient light harness as shown. Secure 20. Reinstall the glove box.
the ambient light harness to the vehicle harness with
three wire ties.
PASSENGER’S
UNDER COVER
VEHICLE
HARNESS 3 WIRE TIES
AMBIENT LIGHT
SELF-TAPPING
SCREW
QC90409AJ
AMBIENT PASSENGER’S
LIGHT UNDER COVER
QC90408AJ
AMBIENT LIGHT QC90410AJ
AMBIENT LIGHT HARNESS 4-PIN
HARNESS CONNECTOR
6 of 7 01671-01 © 2015 American Honda Motor Co., Inc. – All Rights Reserved.
23. Check that all wire harnesses are routed properly
and all connectors are plugged in.
24. Reinstall all removed parts.
25. Reconnect the negative cable to the battery.
26. Press and hold the radio power button for two
seconds to restore the radio and navi (if equipped)
system functions.
27. Reset the clock.
28. Restore the systems back to normal operation as
described in the Service Manual if necessary.
HOW TO OPERATE
• With the light switch set to the “ ” or “ ” position,
the ambient lights are on.
• When the headlight switch is in the “AUTO” position,
the ambient lights are on with the parking lights or
headlights.
• If the ambient lights do not come on, check the fuse and
all the connectors.
LIGHT
SWITCH
QC92501AJ
© 2015 American Honda Motor Co., Inc. – All Rights Reserved. 01671-01 7 of 7