You are on page 1of 9

GTMU Local Commissioning By SMT Procedures

Contents:

- Prerequisites
- Procedures
Prerequisites :

 The TCP/IP protocol is installed on the SMT PC.

 The following uses the Windows 7 operating system as an example to describe how to set the IP
address of the SMT PC.
Procedures:

1. Choose Start > Control Panel ,The Control Panel window is displayed.
2. Choose Network and Internet > Network and Sharing Center > Local Area Connection. The Local
Area Connection Status window is displayed.
3. Click Properties. The Local Area Connection Properties window is displayed.
4. Select Internet Protocol Version 4 (TCP/IPv4), and click Properties. The Internet Protocol Version
4 (TCP/IPv4) Properties dialog box is displayed.
5. Select Use the following IP address and enter the correct IP address, subnet mask, and default
gateway. Ensure that the IP address of the SMT PC is in the same network segment as the IP
addresses (192.168.0.72/255.255.255.0) of the BTS so that a maintenance channel on the BTS
side can be established.

6. Click OK to complete the settings.

7. Connect the SMT PC to the BTS through an Ethernet cable. One end is connected to the
Ethernet port on the main control board of the basic cabinet, and the other end is connected to
the Ethernet port on the SMT PC (usually a portable PC).

8. The IP address and subnet mask of the SMT PC are set correctly. The IP address is in the same
network segment as the IP address (192.168.0.72/255.255.255.0) of the BTS , If the BTS OML
has been established, run the LST BTSLOCALETHPORT command on the BSC LMT to check
whether the ETH port is enabled. If not, run the SET BTSLOCALETHPORT command to enable
the port.

9. Open the MS-DOS Prompt dialog box, On the SMT PC (Windows 2000/XP/7), choose Start >
Run. In the Run dialog box, enter cmd, and press Enter. The MS-DOS prompt dialog box is
displayed

10. Run ping 192.168.0.72 to verify the network connection between the computer and the BTS.

11. Double-click btsm.exe in the software package. The System Login dialog box is displayed :
Below lists the mapping between BTS versions, default user names, and default passwords for logging in
to the SMT

12. Click OK : Figure below site Maintenance Terminal system window will appear
13. Log in to the SMT. Select Site255 , below Parameters should be configured:

14. Log in to the SMT. Select Site255 in the navigation tree and then double-click IP over FE Static IP
in the Function area, confirm the static IP network, and click OK. the Static IP dialog box is
displayed.

15. Click the Config BTS,BSC and VLAN tab. On the Config tab page, set BTS and BSC port IP
addresses and other related parameters.
16. Click OK. The BTS and BSC IP addresses and VLAN information are configured.
17. Click the Static Query tab. On the Static Query tab page, click OK. The static IP addresses and
VLAN information are displayed

18. Click the Config Port IP tab. On the Config tab page, set parameter related to port IP addresses
19. Click OK. Port IP addresses are configured.
20. Click the Config Route tab. On the Config tab page, set parameters for configuring routes

21. Click OK. Routes are configured.


22. Click the VLANMAP/VLANCLASS tab. The VLANMAP/VLANCLASS tab page is displayed
 Configure the VLANMAP
23. During the BTS deployment, you can use the SMT to debug the transport link of the BTS
supporting IP over FE. In this case, you need to configure the Ping function, Set the related
parameters, such as Destination IP and Source IP, based on the settings in the network

You might also like