Professional Documents
Culture Documents
Pages: | 4
\f
CA
v B.Tech. VI Semester (Main/Back) Examination, May-June
\o 2015
Civit Engg.
fEl
\0 6CE4A Design of Concrete Structures-I
Instructions to Candidates:
Attempt any live questions, selecting one question from each unit. All questions
carry equal marks. (Schematic diagrams must be shown wherever necessory.
Any data you feel missing suitably be assumed and stated clearllt. tlnits of
quantities used/calculated must be stated clearly.
Use of following supporting material is permitted during examination.
1. 1.s.4s6(2000)
Unit - I
1. a) With the help ofneat diagram showing "stress distribution" and their typical
values at extreme ends of a rectangular beam section, Describe the balanced
under reinforced and over reinforced section in working stress method. (6)
b) A beam section shown in fig.1 is of M-20 and Fe-415. If this section is used
for a simply supported beam of 4m. effective span then determine the
permissible superimposed working load. (U.d.l) That the beam car^ carry
safely (10)
u*."-' {,}) 'W
,i.,,j',{
***"i l.rt t r|i
r*-" -* -
*8.
,,, ga"-*,Li
"{
;
*". i
'F* ti, "' f ri..$ 1
!
7 .. .h 'qnb\!\-
'
9(':I___---..*-
.:&
t
i'
i t: r:1 ':,tr".
enf"
i
tI
rffi
A"l -" ,).7
'lll{,
U
Unit - II
2. Determine the ultimate moment of resistance of the following sections. Also draw
, the stress block parameters for these sections use M-20 and (2x8) Fe-415
t4** *4
"I rL**-rBe
*!-"ii.tqe!:#-*
t{-# fl
l
&.4r
q"a$# {
*
)0
-&t dse T
*#" i
Prfr"t
6E 6034 ,(2)
OR
2. a) Describe the conditions under which it is advisable to provide doubly reinforced
beams and why? (4)
b) For the intermediate T:beam shown in fig.5 determine the effective flange
width, depth of neutral axis and ultimate moment of resistance of the section
Consider the beam as simply supported over an effective span of 3.6m. Take
M-20 and Fe-415 (r2)
"q.
Unit - III
3. a) Describe the reasons of providing minimum shear reinforcement even if it is
not required theoretically in a beam. (4)
b) Describe the various factors governing the bond strength. (4)
c) For the beam shown in Fig. clesign the minimum shear reinforcement.
Drawthe neat cross-section and longitudinal section showing all
reinforcement (8)
"1
'tuqur''
#- -3- ..}-
. f .
+ .: I rd t
6E 6034 (4)