Professional Documents
Culture Documents
jayaraman
NOTE! These capacities are maximum capacities in a continuous
Metso Portable Solution for Aggregate Production troublefree operation when feed material quality and distribution
curve corresponds to the theoretical curve used in this calculation.
Feed
600mm Material
coarse Material Characteristics
SD 2.7 t/m3 Feed Analysis Considered : Preliminary Flow Sheet for Discussions based Long term capacities will fluctuate due to the variations in the feed
Granite Cr 35 % (-) 20 mm : 12% on Considered Feed Gradation & Material Characteristic. and operating intensity of the plant.
Considered :
Abr 1398 g/t (-) 38 mm : 19%
Material : Granite It will be fine tuned after material testing.
Metso Minerals does not guarantee any of these figures without our
182 t/h Solid Density : 2.7 t/cum (-) 75 mm : 30% Note:- Feed Gradation is very important parameter
separate written approval based on a detailed study of the case.
Crushability : 35% (-) 150 mm : 45% & it needs be Confirmed by Customer based on
Contamination : Free from Clay (-) 300 mm : 70% which equipment selection may change
Moisture : Dry (-) 500 mm : 93% Feed is blasted rock & well graded without any metallic/un-crushable pieces.
(-) 600 mm : 100% Any Variation in feed gradation and material characteristics Feed is whole of dry un-segregated homogenous "as blasted feed" without clays
then considered will effect Plant Performance in Capacity and other deleterious materials. No fraction is taken out, no fraction is manually
and Product Gradation. broken, and the blasting pattern is in conformity with international practices.
Feed should be free from clay, fines, moisture etc
Higher than indicated moisture in the feed would Material to be free from contamination e.g. Clay, Wood, Glass, plastic, metal,
otherwise no guarantee on plant performance by Metso
Grizzly Feeder if Primary Feeding circuit is choking/jamming effect in Plant Performance and results in iron pieces refuge, etc.
reduction in capacity and product generation.
TK11-42-2V
182 Opening 90 mm
108
NW106
74 108
C106
std 165
165
20 m3 Vibrating Feeder
Slot Sizer
TK deck
Setting 85 mm
Surge Bin Feeder 20 m3 Tertiary Stage
108 TKP 10-20
74 #22 mm TKP 10-20
Surge Bin NW 7150 D
58 165 Automation IC3
17 165
58
Metal Detector
223
0 58 GP220
17 NW220GPD extra coarse 173
223
Dual Slope 10sqm 173 Tip Speed will
Screen on Board adjusted at Site
0 223 DS18 55
Quarry Fines DS18 55 #24 mm
#45 mm 173 #16 mm
#10 mm
Quarry Fines should 0 223 #24 mm
#12 mm #6 mm Dual Slope 10sqm
always be tapped #6 mm Screen on Board
8
7 25
50 30
Feed rate may vary in the range of +/- 10% GSB 26
77 25% split 83 0
depending on Feed Gradation, Material 55 34
incredent 50
Characteristics & Jaw Crusher setting. Cone product.No guarantee 25
25
on Gradation. Top size depends 26 25% split
0
on cone CSS in open circuit. 25% split incredent 0
if material characterstic actually fed to the plant is 50
incredent 34
harder than it will have impact plant performance 0 26 0
and Feed rate
34 0
Crushers Settings are tentative. It will be
finally selected after material testing & 0
83 26 30 25
adjusted at site as per product requirement.