Professional Documents
Culture Documents
1. What is the recommended carrier deck 6. It is acceptable to drag a Luxury Vehicle onto
retention method for Luxury Vehicles? a carrier deck while locked in park provided
A. Retain vehicle with J-Chains, V-Bridle, and the manufacturer’s recommended attachment
draw down with the winch.
points are used.
B. 8 Point Tie Down Kit
A. True
C. Choking lasso straps through all 4 wheels
B. False
D. Place unit in Park, set parking brake, and
drive slowly if close to the service facility
7. What is the recommended connection
method for Tow Eyelet vehicles for winching
E. Any of the above is an acceptable method.
onto the carrier deck?
A. Make the winch line hook connection
2. A flat blade screwdriver is an acceptable tool
directly
to use for the removal of interior trim panels
when accessing override provisions. B. Using a small chain
A. True C. With an offset kit consisting of small
endless loop, secondary safety strap, &
B. False
snatch block
3. Vehicle Inspection Forms should be D. V-Bridle with Large Hooks to the
completed on which vehicles? suspension
A. Every vehicle
E. All of the above are acceptable methods.
B. Only those with prior damage
8. What is the recommended procedure for
C. Only those vehicles damaged by the loading Luxury Vehicles which have T-Slot
Service Provider
provisions?
D. Luxury and High Performance vehicles
A. Nylon Bridle with cluster sets
E. Only those requested by Agero at time B. Nylon Bridle with J-Hooks
of dispatch
C. Chain Bridle with cluster sets
4. Wheel Lift Towing of Luxury Vehicles is D. Chain Bridle with J Hooks
an acceptable alternative when a Carrier/ E. All of the above are acceptable methods.
Rollback is not available.
A. True 9. Personal appearance is as relevant as having
the right equipment and ability to perform a
B. False
Towing or Service Event.
5. Wheel Lift and Dolly Towing of Luxury A. True
Vehicles is an acceptable alternative to B. False
dragging a unit onto a carrier deck in Park.
A. True
B. False
10. All Luxury Auto Manufacturers engineer a 16. Special care should be taken with which of
Park Override mechanism into their vehicles. the following when using 8 Point Tie Down
A. True
Kits while transporting vehicles on carriers?
B. False A. Finish on the Wheels
B. Brake Lines
11. The best way to recover a vehicle’s dead C. Sensor Wires
battery is with a jump box or truck mounted D. Bumper Covers
jumper cables.
E. None are of any concern
A. True
F. All are of concern
B. False
17. During Carrier Towing, Full Electric and
12. The preferred method for loading vehicles Hybrid Vehicles
with low approach and departure angles is
A. Should have their high voltage battery
with:
circuit disconnected
A. A low profile, air ride carrier
B. Should have the 12 Volt start battery
B. Race Ramps
disconnected
C. Wrecker and Dollies
C. Can be transported in the same fashion as
D. Both A&B
any gasoline vehicle
E. None, the vehicle will need to be repaired D. Are to be grounded to the carrier deck to
on site.
prevent shock from electric discharge
13. What are the special concerns when handling 18. When loading a vehicle with an automated
vehicles which have no spare tire. manual transmission to a carrier
A. Reduced approach or departure angles A. The Operator should verify the vehicle is
during loading for Tow
in gear before loading
B. Repairing the tire roadside
B. The Operator should verify the vehicle is in
C. Locating the wheel lock
neutral before loading
D. A flat spare tire
C. The Electronic Parking Brake should be
engaged
14. A trickle charger can recover a vehicle’s D. The battery should be disconnected
battery back to full state of charge.
A. True 19. Proper installation of the Tow Eyelet is:
B. False A. Screwed into the bumper beam with the
shoulder fully seated
15. Chocking wheels with lasso straps is a B. Screwed into the bumper beam until
preferred method of carrier retention. it stops then backed out one half turn
A. True
C. To turn it a few times and that is
B. False good enough.
D. What’s a Tow Eyelet?