Professional Documents
Culture Documents
QUESTION BANK
ECD&A
The phase difference between the output and input voltage of a CE amplifier is ___________.
The output power of the transistor amplifier is more then the input power because addition power is
supplied by ___________________.
The ______________ gain for the fixed-bias and self bias JFET configuration is the same.
For all transistor amplifiers, the no load gain is always _____________ then the loaded gain.
The gain from source to load is always _____________ by the internal resistance of the source.
The ________________ gain of an amplifier is very sensitive to the input impedance of the amplifier and
the applied load.
The ________________ has the highest input impedance and the lowest output impedance of the three
amplifier configuration.
A mode of op-amp operation in which a single voltage is applied to only one input is called___________.
A _______________mode of op-amp operation in which two apposite polarity signal voltage are applied
to the two inputs.
The ratio of a change in drain current for a change in gate to source voltage is called ________________.
______________ is the drain-to-source voltage of a FET at which the drain current become constant
when the gate-to-source voltage is zero.
A channel is induced in an ________________ by the application of a VGS greater then the threshold
value.
The high input resistance of a JFET is due to this _______________ greater junction source.
A Common Collector amplifier has a good voltage gain but it has a very low input resistance.
The parameter hfe correspond to ______________.
In a common-emitter amplifier with the voltage divider bias ,Rin(base)= 68kohm, R1=33k ohm and
r2=15k ohm . The total input resistance is ____________ohm.
The CE amplifier is driving a 10 k ohm load. If RC is 2.2 k ohm and r`e= 10 ohm, the voltage gain is
approximately ___________.
The cathode of a ___________ diode in a voltage regulator is normally more positive then anode
A __________ diode exhibits variable capacitances that depend upon reverse voltage.
For operation as an amplifier, the base of the ____________ must be positive with respect to the emitter.
When operated in cutoff and saturation, the transistor acts like a ______________.
In a zero level detector, the output changes state when the input ______________.
The quality factor of a band pass filter is depending upon the _____________________.
When the gain of the filter is minimum at its center frequency, it is ____________________
Comprehension paper
When in inverting amplifier both R1 and Rf are reduced to zero, the circuit functions as
a. voltage follower
b. comparator
c. integrator
d. differentiator
The common base amplifier provides _____________________ voltage and power gain.
a. Low
b. Unity
c. High
d. No gain
The emitter follower amplifier is also known as
a. Common emitter amplifier
b. Common base amplifier
c. Common collector amplifier
d. None of the above is true
For a transistor in class A amplifier, the collector current flows for the ________________of input
waveform.
a. 360°
b. 270°
c. 180°
d. 120°