Professional Documents
Culture Documents
Power off the Video Server as soon Keep the Video Server away from
as smoke or unusual odors are water. If the Network Camera
detected. becomes wet, power off immediately.
Contact your distributor in the event of Contact your distributor in the event of
occurrence. occurrence.
Do not place the Video Server around Refer to your user's manual for the
heat sources, such as a television or operating temperature.
oven.
Keep the Video Server away from Do not place the Video Server in high
direct sunlight. humidity environments.
1
Do not place the Video Server on Do not touch the Video Server
unsteady surfaces. during a lightning storm.
Do not disassemble the Video Server. Do not drop the Video Server.
2
English
1 Package Contents
3
2 Physical Description
Front Panel
SD Card
Back Panel
Ethernet 1 2 3 4 5 6 7 8
4
English
3 Network Deployment
CAMERA NO.
POWER
MIC OFF ON
1 2 3
OUT
VIDEO IN OUT
4. If you have external devices such as sensors and alarms, connect them to the general
I/O terminal block.
5. Connect the Video Server to a switch via Ethernet cable.
6. Connect the power cable from the Video Server to a power outlet.
1: Power +12V
2: Digital output
3: Digital input 4
4: Ground
5: AC 24V
6: AC 24V
7: RS485+
8: RS485-
5
Ethernet Switch
6
POWER LINK
COLLISION RECEIVE
1 2 PARTITION
3 4 5
5
Power over Ethernet (PoE)
When using a PoE-enabled switch
The Video Server is PoE-compliant, allowing transmission of power and data via a
single Ethernet cable. Follow the below illustration to connect the Video Server to a
PoE-enabled switch via Ethernet cable.
POWER LINK
COLLISION RECEIVE
PoE Switch
1 2 PARTITION
3 4 5
POWER LINK
COLLISION RECEIVE
1 2 PARTITION
3 4 5
Non-PoE Switch
6
English
4 Assigning an IP Address
1. Install "Installation Wizard 2" from the Software Utility directory on the software CD.
2. The program will conduct an analysis of your network environment. After your network
is analyzed, please click on the "Next" button to continue the program.
IW2
Installation
Wizard 2
3. The program will search for VIVOTEK Video Receivers, Video Servers, and Network
Cameras on the same LAN.
4. After searching, the main installer window will pop up. Click on the MAC that matches
the one labeled on the bottom of your device to connect to the Video Server via
Internet Explorer.
Video Server
Model No: VS8102
00-02-D1-73-02-02 192.168.5.151 VS8102
MAC:0002D1730202
R o HS 0002D1730202
This device complies with part 15 of the FCC rules. Operation is subject to
the following two conditions:
(1)This device may not cause harmful interference, and
(2) this device must accept any interference received, including interference
that may cause undesired operation.
Made in Taiwan
7
5 Ready to Use
For further setup, please refer to the user’s manual on the software CD.