Professional Documents
Culture Documents
Contents
3.1.7 BTS3902E Technical Specifications
RF Specifications
Table 2 lists radio frequency (RF) specifications of a BTS3902E.
Table 2 BTS3902E RF specifications
NOTE:
The receiver sensitivity is measured, as recommended in 3GPP TS25.104, at the antenna connector over the full
band on condition that the channel rate reaches 12.2 kbit/s and the bit error rate (BER) does not exceed 0.001.
The maximum output power equals the maximum output power of the power amplifier minus the internal loss.
The maximum output power is measured at the antenna connector in the RF module.
NOTE:
The "1 x A" column under Configuration indicates that one sector is configured with A carrier (s).
The typical power consumption level is reached when the base station works with 40% load, and the
environment temperature is 25°C.
The maximum power consumption level is reached when the base station works with 100% load, and the
environment temperature is 25°C.
When working on the 850 MHz band, the BTS3902E supports only single-antenna transmission, not supporting
dual-antenna transmission and MIMO.
Signaling Specifications
Table 10 lists the signaling specifications of a BTS3902E.
AWS >6
Engineering Specifications
Table 13 lists the equipment specifications of a BTS3902E.
BTS3902E 110V/220V AC, 1900 MHz /2100 MHz 1900 MHz /2100 MHz
90/180V AC to /AWS: /AWS:
135/290V AC 300 mm x 270 mm x 11 (without the
–48 V DC, –36 V DC to 120 mm (without the antennas and the
–57 V DC antennas and case) case)
300 mm x 277 mm x 13 (with the antennas
NOTE: 145 mm (with the and the case)
The DC power module is antennas and case) 850 MHz:
compatible with only RF 850 MHz:
units that operate on the 14 (without the
AWS frequency band. 300 mm x 270 mm x antennas and the
127 mm (without the case)
antennas and case) 16 (with the antennas
300 mm x 277 mm x and the case)
170 mm (with the
antennas and case)
Common mode 10 kA