OPTIONAL EQUIPMENT
CNC CENTRE LATHES
4 STATION INDEXING TURRET
DUPLOMATIC TYPE TRM 160 SERIES 21
FITTED TO CNC 3000 AND CNC 4000 MACHINES.
TECHNICAL SPECIFICATIONS
Nr. Positions
Direction of rotation
Unbalancing torque with horizontal Nm 25
axis
Max upsetting torque with thrust Nm 1600
downwards
Max upsetting torque with thrust Non 1300
upwards
Max tangential torque Nm 1500
Outrigger of the tool from the mm 180
rotation axis of the turret (considered
for the calculation of the torque)
Moment of of transportable Ke m* 1
weights
Transportable weights Kg 50
Repeatability precision +2"
Angular speed of rotation rad/sec 3
Time for: - Lifting see 0.35,
- Turning through 90° sec 0.5
= Locking sec 0.45
= Total time sec 1.3
Power of electric motor Kw 0.12
Short circuit current of the motor A 6
@ supply voltage a 110v S0Hz
17CNC CENTRE LATHES
DUPLOMATIC TURRET TRM 160 SERIES 22
¢ Section
Section B
@ Spread coupling surface with Loctite 573
@ Seal with Loctite Tubermetic 572TRM 160 SERIES 21
FAULT FINDING
FAULT
Rotary Table does not start
Rotary Table keeps turning
without stopping
station.
Rotary Table lowers but does
not lock.
Rotary Table
still on load.
locks but motor
Rotary Table stops
between position.
in an in-
in the required
is
CNC CENTRE LATHES
CAUSES ~ REMEDIES
= Check current feeding to
motor. Must be of adequate
voltage.
- Check motor for correct
sense of rotation.
- Motor overheated. Let it
cool until thermodetector
allows new cycle to start.
~ Check motor for breakdown.
If required replace motor.
- Commutator does not operate
{damaged}. Replace it.
- Microswitch is in a wrong
position (too high).
By acting manually on
worm screw, lock Rotary
Table then place microswitch
in proper position (Imm
about ahead of locking).
- Microswitch is in a wrong
Position (too low).
Act as above described
(Imm about ahead of
locking).
- Make sure that allowable
load values are not
exceeded.
- Check Electrical connections
- Check current feeding
Check microswitch (226) for
trouble. In case of
breakdown, act as follows:
Operate Rotary Table
manually by means of
worm screw square
connection, to restore
lock position.
Replace microswitch.