You are on page 1of 2

ELECTRONIC CIRCUITS

4-8 CHANNELS MULTIPEXED EMITTER


The I-95 module is a 4-8 channels multiplexed emitter to control I-96 and I-97 modules. Using two cables,
I-95
you could connect emitter and receiver and then independently control up to 8 loads, with 600m as
maximum distance between emitter and receiver. Communication is done closing push button or switch
contacts (4 for the I-96 and 8 for the I-97), controlling their corresponding load in the receiver module. As it is
supplied trough the communication cable, any additional power supply is necessary.

TECHNICAL CHARACTERISTICS.
Voltage.................................................................................................................. Not Necessary
Minimum Consumption........................................................................................ 10 mA.
Maximum Distance............................................................................................... 600 m.
To Control Receiver................................................................................................ I-96 & I-97

OPERATING.
COMMUNICATION CABLE. As the I-95 module is supplied through the communication cable, this one will be
the single connection with receivers.
For industrial installation or with a high parasites level from the mains, you have to use a shielded cable,
connecting wires to the negative terminal and the interior cable to the positive.

OPERATING. Connect each "INT" switch to the corresponding terminals as it is indicated in the wiring map.
Supply the receiver (see the receiver's instruction manual). When these operations will be done, to connect
wished relay(s) close the corresponding switch or push button.

CONNECTION MAP.

INT 1 (RELAY 1)
INT 8 (RELAY 8)

INT 7 (RELAY 7)

INT 6 (RELAY 6)

INT 5 (RELAY 5)

INT 4 (RELAY 4)

INT 3 (RELAY 3)

INT 2 (RELAY 2)

COMMUNICATION
CABLE

I-95

1
AUTOMATISMOS Ref. Full9701
I-95
HOW TO INSTALL.

INT 1 (RELE 1)

ALIMENTACION

I-95
RECEPTOR

CABLE DE
COMUNICACION
INT 2 (RELE 2)

INT 4 (RELE 4)

INT 5 (RELE 5)

INT 6 (RELE 6)

INT 7 (RELE 7)

INT 8 (RELE 8)
INT 3 (RELE3)

SUGGESTIONS.
Connection of the Communication cable. You had to correctly connect communication cable
between emitter and receiver. Do not confuse module input with power supply input. See receiver's

TECHNICAL SUPPORT AND INFORMATION.


For any questions or more information:
By Fax. (24h.) +34.3. 432.29.95
By Mail: C/ Quetzal, 17-21, Entlo. 2º (08014) BARCELONA - SPAIN.
By E-Mail: cebek@sakma.es
Keep you invoice. For any repairing could you send this with module. Else, the module will lost the warranty.

All the module’s CEBEK have 3 years of total warranty in thecnical


repairing, and spares from the date of buy.
CEBEK is trade make of FADISEL S.L. more than 300 module’s are avaible in
stock for any purpose request our CATALOGUE, or visit our Web.
Http://www.sakma.com/CEBEK Y EAR S
2

You might also like