Professional Documents
Culture Documents
INDEX
PREPARED BY:
APPROVED BY:
CLIENT : #REF!
YAMUNA NAGAR
INDIA PLANT : #REF! PAGE:
Shell Material =
Since provided shell thickness is more than the required minimum thickness, HENCE SAFE
CLIENT : #REF!
YAMUNA NAGAR
INDIA EQPT. : #REF! PAGE:
Since provided shell thickness is more than the required minimum thickness, HENCE SAFE
3
Kg/cm2 (g)
4
Kg/cm2 (g)
CLIENT : #REF!
YAMUNA NAGAR
INDIA PLANT : #REF! PAGE: 5
Head Material =
Design Pressure = Kg/cm2 (g)
Inside Diameter of head = mm
Design Temperature = 0
C
Nominal thickness of head Tnom = mm
Outside Diameter of head D = 0 mm
Height of the head H = 0.0 mm
Ratio H / D = #DIV/0!
Shape factor ( From FIG. - 23D ) K =
Factor of additive thickness C = mm
( As per ASME Sec II, Part D) f = Kg/cm2
[Ref. Ammendment dated 29.11.03]
Since adopted minimum thickness is more than the required minimum thickness
###
CLIENT : #REF!
YAMUNA NAGAR
INDIA PLANT : #REF! PAGE: 6
SHELLSIDE
K = ( P * D ) / ( 1.82 * f * e )
O.D. of shell D = mm
K = #DIV/0!
Also Drum dia ( D ) x Thickness( T ) in inches = 0.00
TUBESIDE
K = ( P * D ) / ( 1.82 * f * e )
O.D. of shell D = mm
K = #DIV/0!
Also Drum dia ( D ) x Thickness( T ) in inches = 0.00
DESIGN DATA
NOZZLE DATA
SHELL DATA
Material of Shell
Shell I.D (Corroded) D mm
Provided Shell Thk.(Corroded) Ts mm
Min tensile strength of shell S kgf/mm²
Allowable stress f psi (ASME Sec II, Part D)
Thk of equivalent smls. Shell T1 mm WP * D #DIV/0!
[AS PER REG.270] Eqn.72 2 * f * E - WP
Area Required :
To be Compensated A mm² W*T1 #DIV/0!
Area available :
From Shell NO B mm² 2*(3+Ts)*(Ts-T1) 0.00
ITEM NUMBER :
SERVICE :
REV DATE PREPARED BY APPROVED BY
Format No # EN-FT-3010, Rev-0
Date
PPROVED BY
CLIENT : #REF!
PLANT : #REF!
Calculations
REV. 0
Format No # EN-FT-3010, Rev-0
Discipline
ng
Rev. Date
Calc No.
Prepared By
Checked By
Approved By
FORMAT FOR
EERING CALCULATIONS