I use this version of the ST10flasher, is the best version.
Thank you very much Mac Gyver, you are really helpfull :top: Can you confirm me that i understand what the terminals are? http://i48.tinypic.com/mbls3d.jpg Mac Gyver 6th November, 2012, 11:09 AM can be with this terminal or other type, it is important to stay well connected and do not touch adjacent pins, leaving the short circuit. chokchman 6th November, 2012, 12:08 PM can be with this terminal or other type, it is important to stay well connected and do not touch adjacent pins, leaving the short circuit. Ok now it's very clear for me! The VAG-COM that i showed you in the ebay link is ok?because i think i will buy it! Mac Gyver 6th November, 2012, 08:05 PM the VAG-COM that showed works fine. chokchman 7th November, 2012, 11:44 AM The two 560R resistors that i must place in the ECU following the photo that you sent me are essential?i can't read or write without them? Mac Gyver 8th November, 2012, 01:32 AM yes are essential. chokchman 9th November, 2012, 08:46 AM Hello all yesterday i have installed ST10flasher on my PC and i have tried to launch it, just by curiosity, to see what it looks like and i had these error messages:
http://i47.tinypic.com/2ppnbpu.jpg
http://i45.tinypic.com/1ear15.jpg
Do you know what does it means?i specify that i did not connect interface or ECU because i have nothing yet
MacBook Pro (M1 Chip) User Guide: The Ultimate Basics Guide for Beginners And Seniors to Setup And Master the New MacBook Pro Apple (M1 Chip) with Tips & Tricks