This document summarizes the design of a tension member made of S275 steel. It calculates the ultimate tension force of 463 kN and verifies that the tension capacity of 1134.1 kN from the welded connection of a 120x120x10 mm single angle section exceeds the required force. Material properties, section properties, and the tension capacity calculation are shown in accordance with design codes BS 5950 and BS 8110. The member passes the tension capacity check.
This document summarizes the design of a tension member made of S275 steel. It calculates the ultimate tension force of 463 kN and verifies that the tension capacity of 1134.1 kN from the welded connection of a 120x120x10 mm single angle section exceeds the required force. Material properties, section properties, and the tension capacity calculation are shown in accordance with design codes BS 5950 and BS 8110. The member passes the tension capacity check.
This document summarizes the design of a tension member made of S275 steel. It calculates the ultimate tension force of 463 kN and verifies that the tension capacity of 1134.1 kN from the welded connection of a 120x120x10 mm single angle section exceeds the required force. Material properties, section properties, and the tension capacity calculation are shown in accordance with design codes BS 5950 and BS 8110. The member passes the tension capacity check.
0.5 Table 11 Constant (275/py) ε = 1 Modulus of elasticity E = 205000 N/mm2
Section Properties
Single Angle Section Properties:
Gross cross section Area Ag = 23.2 cm2 d = 120 mm b = 120 mm d t = 10 mm Radius of gyration in XX rx = 3.67 cm Radius of gyration in YY ry = 4.63 cm b Radius of gyration in VV rv = 2.36 cm4 Ixx = 313 cm4 Iyy = 497 cm4 Ivv = 129 cm4
Double Angle Section Properties:
Ag = 46.40 cm2 space between angles = 10 rx = 3.67 cm ry = 8.70 cm
Table 11 Thickness of gusset plate tg = 10 mm
Clause 4.6.3.2 Tension capacity
Gross section area of connected element a1 = 120 x 10