Professional Documents
Culture Documents
Revision: 01
B767 Rev. date: 05-08-2010
Page: 1 of 4
TASK TITLE/NAME: CLEAN TOILET LINES WITH CRUSHED ICE MECH INSP
1. General M
A. This procedure gives the instructions to clean the vacuum waste tubes.
Use this procedure to decrease the scale that collects in the vacuum waste
tubes.
B. These task gives 2 pocedures to keep waste lines clean. Use Method I (crushed
iced and Honey Bee Cleaner 60) to acomplish this task. You may use Method II
as an alternate if Method I can´t be acomplish.
(3) Pressure Test (used before the Soak or Recirculate Methods to make
sure that the waste lines will not leak)
(6) Off-Aircraft Soak Procedure for Cleaning the Vacuum Waste Lines
TASK 38-32-00-177-050
A. Consumable Materials
Form OP-002-R00
Fleet Aircraft Reg Task Number: B767-142
Revision: 01
B767 Rev. date: 05-08-2010
Page: 2 of 4
TASK TITLE/NAME: CLEAN TOILET LINES WITH CRUSHED ICE MECH INSP
B. References
C. Access
(1) Location Zone
200 Upper Half of Fuselage
S 867-003
(1) Supply electrical power (AMM 24-22-00/201).
S 617-002
(2) Do the procedure for the waste tank servicing (AMM 12-17-01/301).
S 047-169
(3) AIRPLANES WITH PRECHARGE SHUTOFF VALVE;
To hold open the precharge shutoff valve, do this task:
Deactivate the Precharge Shutoff Valve, AMM 38-32-00/201.
S 177-078
(4) Add 20 gallons (75 liters) of water to each waste tank.
S 867-004
(5) Pressurize the potable water system (AMM 38-10-00/201).
E. Procedure M
NOTE: Use one of the following methods to periodically clean the waste
lines.
S 117-005
(1) Method I (Crushed Ice and Acid)
Do these steps for each toilet in the airplane, one toilet at a time, if you
are using the Honey Bee 60 Cleaner, or the Acetic Acid (B50113).
Form OP-002-R00
Fleet Aircraft Reg Task Number: B767-142
Revision: 01
B767 Rev. date: 05-08-2010
Page: 3 of 4
TASK TITLE/NAME: CLEAN TOILET LINES WITH CRUSHED ICE MECH INSP
(c) Flush the toilet with approximately 1.0 gal. (4 liters) of fresh water to
remove the toilet system cleaner from the toilet bowl.
S 117-193
(2) Method II (Chemical Without Crushed Ice)
Do these steps for each toilet in the airplane, one toilet at a time, if you
are using the Glycolic Acid cleaner, B50091 (Gly-Vak).
Form OP-002-R00
Fleet Aircraft Reg Task Number: B767-142
Revision: 01
B767 Rev. date: 05-08-2010
Page: 4 of 4
TASK TITLE/NAME: CLEAN TOILET LINES WITH CRUSHED ICE MECH INSP
(b) Flush the toilet to put the toilet system cleaner into the waste line.
(c) Flush the toilet with approximately 1.0 gal. (4 liters) of fresh water to
remove the toilet system cleaner from the toilet bowl.
(d) Let the toilet system cleaner stay in the waste lines as long as
practical.
S 447-170
(1) AIRPLANES WITH PRECHARGE SHUTOFF VALVE;
To close the precharge shutoff valve, do this task:
Reactivate the Precharge Shutoff Valve, AMM 38-32-00/201.
S 617-006
(2) Do the procedure for the waste tank servicing (AMM 12-17-01/301).
S 867-007
(3) Remove electrical power if it is not necessary (AMM 24-22-00/201).
Form OP-002-R00