Professional Documents
Culture Documents
were correct at the time of going to print. We reserve the right to make any changes
necessary in line with continuous development and improvement.
This publication may not be duplicated, reprinted, stored in a data processing system or
transmitted by electronic, mechanical, photographic or other means, or recorded,
translated, edited, abridged or expanded without the prior written consent of Ford-Werke
GmbH. The same also applies for parts of this manual and their use in other publications.
Although due care has been taken to make this publication as complete and accurate as
possible, it can still be subject to alterations.
This publication describes options and trim levels available throughout the Ford model
range in every European country, and therefore some of the items covered may not apply
to your vehicle.
Important: Ford genuine parts and accessories have been specifically designed for Ford
vehicles. They are dedicated for your Ford vehicle.
We would like to point out that other parts and accessories than mentioned above have not
been examined and approved by Ford unless explicitly stated by Ford. In spite of
continuous market product monitoring, we cannot certify the suitability of such products.
Ford is not liable for any damage caused by the use of such products.
E Copyright 2005
Issued by Ford-Werke GmbH, Ford Customer Service Division
Quick start 2
Introduction 12
Instrumentation 14
Vehicle information systems 22
Climate controls 36
Lights 46
Driver controls 54
Locks (security) 64
Seating and safety restraints 77
Driving 98
Roadside emergencies 138
Cleaning 161
Maintenance 163
Capacities and specifications 172
Index 184
Quick start
STORAGE AREAS Storage compartment
Front storage compartment
Card holder
Coin holders
Pen/pencil clip
2
Quick start
Under-seat storage Storage pockets
The storage box is located under
the front passenger seat.
Driver’s seat
• To open: Pull the front of the seat
cushion up . Rear seats
• Pull the seat cushion towards the
instrument panel .
• Lift the seat cushion to reveal the
storage area .
• To close, follow the above steps in
reverse, making sure that you push
the seat cushion downwards until it
locks into place.
3
Quick start
Map pockets FOLDING THE REAR SEAT
(front seats) CUSHION AND SEATBACK
FORWARDS
4
Quick start
MULTIFUNCTION DISPLAY MESSAGE CENTRE
For details, refer to page 20 For details, refer to page 20
onwards. onwards and page 22 onwards.
5
Quick start
Functions of the main menu Personalised settings
The following personalised settings
are available on the Message
Centre:
• Remote unlocking
The vehicle can be set to unlock
Press the RE/SET button briefly to only the driver’s door or to unlock
scroll through the following menu all doors when the button is
functions: pressed once.
• Distance to empty • Lane change indicators
• Average speed The direction indicators can be set
• Average fuel to flash three times when the
• Fuel economy multifunction lever is tapped up or
(depending on country) down.
• Time setting • Radio display
(when the vehicle is stationary The Message Centre can display
and depending on audio system some audio system information.
fitted) • Hazards on heavy braking
• Individual settings The hazard light can be set to flash
(when the vehicle is stationary) automatically if the brakes are
• Warning and info messages applied abruptly (e.g. emergency
Press and hold the RE/SET button braking).
to change or reset the desired • Chimes
function or to enter the settings Some of the convinience chimes
menus. can be deactivated.
• Language menu
Different languages can be chosen
to be used for the display.
6
Quick start
CLIMATE CONTROLS
For details, refer to chapter
Climate controls, page 36 onwards.
Screen defrosting/demisting
On vehicles with Electronic
Automatic Climate Control press
the button. This will activate
the heated screens as well as
selecting the maximum
temperature and blower speed.
If the button is pressed again,
the system returns to the previous
Set the blower to position 3 or 4, setting. The heated screens switch
select the maximum temperature off automatically after a short time.
and set the air distribution control
to . Switch on the air
conditioning (if equipped) to
support demisting.
If necessary, switch on
the heated front screen and
the heated rear screen.
7
Quick start
Rapid cooling of the vehicle LOCKS (SECURITY)
interior For details, refer to chapter Locks
(security), page 64 onwards.
Locking/unlocking the vehicle
8
Quick start
AUDIO SYSTEMS DIESEL LOW FUEL SAFETY
For details, refer to the separate MODE
manual. Diesel engines must never run out
of fuel. They have safety devices to
Automatic volume control (AVC) prevent this. They will reduce
This function increases or engine power by up to 30 % when a
decreases the volume of the audio low fuel level is detected, as
system relative to the vehicle indicated by the low fuel warning
speed. For personal settings, refer light.
to the separate manual. The system will also shut down (i.e.
the engine will stop completely)
Setting the time and date just prior to reaching zero fuel to
To enter the settings mode press prevent re-starting problems and,
the CLOCK button on the audio more importantly, severe engine
system. damage.
Press the A or " button to toggle To start the engine, see the section
between time and date. Diesel low fuel safety mode on
page 124.
To set the time/date turn the rotary
control. Benefits of the diesel low fuel
Press the CLOCK button to save safety mode
the setting and exit the settings This mode maximises fuel
mode. efficiency under very low fuel
conditions and helps to prevent:
• Running out of fuel too quickly
• Clogging the fuel system
• Placing excess pressure on the
engine, that would result in costly
and severe engine damage
9
Quick start
ELECTRICAL FEATURES On vehicles with Autolamps:
Autolamps
For details, refer to page 46
onwards.
10
Quick start
Welcome lights Power folding mirrors
For details, refer to page 49. For details, refer to page 60.
The side and tail lights will switch
on automatically for 25 seconds
when the door is unlocked using
the remote control. Once all doors
are closed, the welcome lights will
switch off automatically after
5 seconds or at once if the ignition
is switched on.
Autowipers/intermittent wiping With the interior switch in the
centre position, push the control
For details, refer to page 55 unit down to fold the mirror. To
onwards. return the door mirror to its original
Depending on the model variant, position push the control unit down
auto wipers or intermittent wiping again.
are selected by moving the wiper Press the button once to lock the
lever one position upwards. vehicle: the door mirrors will fold
When the ignition is switched on automatically if they are not already
with the wiper lever in the folded back using the control unit.
Autowipers position, the wipers will Press the button once to unlock
not cycle until water is detected on the vehicle: the door mirrors will
the front screen. unfold automatically if they were
automatically folded back.
11
Introduction
PREFACE Regular servicing of your vehicle
Congratulations on acquiring your helps maintain both its road-
new Ford. Please take the time to worthiness and its resale value. A
get well acquainted with your network of more than 7 000 Ford
vehicle by reading your owner authorized repairers throughout
literature. The more you know and Europe can help you with their
understand about your vehicle the professional servicing expertise.
greater the safety, economy, and Their specially trained personnel
pleasure you will derive from are best qualified to service your
driving it. vehicle properly and expertly. Also,
they are supported by a wide range
The Owner’s Handbook describes of highly specialised tools and
every option and model variant equipment specially developed for
available in every European servicing Ford vehicles.
country and therefore some of the
items covered may not apply to Remember to pass on the
your particular vehicle. Owner’s Handbook when
Furthermore, due to printing reselling the vehicle. It is an
cycles it may describe options integral part of the vehicle.
before they are generally
available.
12
Introduction
FOR YOUR SAFETY AND RUNNING IN
ENVIRONMENTAL PROTECTION Avoid driving too briskly during the
first 1 500 km. Vary the speed
Warning symbols in frequently and change up a gear
this handbook early. Avoid labouring the engine.
How can you reduce the risk of New tyres require a running-in
personal injury and prevent distance of approximately 500 km.
possible damage to others, your During this period, the car may
vehicle and its equipment? In this exhibit different driving
handbook, answers to such characteristics. Therefore, avoid
questions are contained in driving too briskly during the first
comments highlighted by the 500 km.
warning triangle symbol. If possible, you should avoid heavy
Note: Important information is also use of the brakes for the first
given in paragraphs starting with 150 km in town and for the first
the highlighted word Note. 1 500 km on motorways.
From 1 500 km onwards you can
Warning symbols on gradually increase the performance
your vehicle of your vehicle up to the permitted
maximum speeds.
When you see this
symbol, it is imperative We wish you safe and pleasurable
that you consult the driving with your Ford vehicle.
relevant section of this
handbook before touching or
attempting adjustment of any kind.
13
Instrumentation
Ventilation vents 36
14
Instrumentation
15
Instrumentation
16
Instrumentation
17
Instrumentation
The following warning and indicator If a warning or indicator light does
lights illuminate when the ignition not illuminate when the ignition is
is switched on: switched on, it indicates a
• ABS malfunction. Have the system
(depending on model variant) checked by an expert.
• Airbag/seat belt pretensioner
• Brake system
• Doors open
(depending on model variant)
• Engine
• Engine immobilisation
• ESP
(depending on model variant)
• Frost
• Ignition
• Oil pressure
• Power assisted steering
(vehicles with 1.6 l Duratorq-TDCi
engine)
• Transmission/engine systems
18
Instrumentation
GAUGES
Tachometer Switch off the ignition and
On vehicles with a diesel engine, determine the source of the
the tachometer goes to problem once the engine has cooled
6 000 revolutions per minute. down.
Refer also to section Cooling
Engine coolant temperature system reservoir, page 169.
gauge
Fuel gauge
At normal operating temperature,
the temperature indicator remains The arrow adjacent to the fuel
within the centre section. pump symbol indicates on which
side of the vehicle the fuel filler cap
If the needle enters the red section is located.
and/or the Engine coolant
temperature warning appears, the Speedometer
engine is overheating.
19
Instrumentation
Multifunction display or • Distance to empty
Message Centre Indicates the approximate distance
Depending on the model variant, the vehicle will travel on the fuel
the vehicle is equipped with a remaining in the tank. Changes in
multifunction display or a display driving pattern may cause the value
for the Message Centre. to vary.
The display is activated when the
driver’s door is opened or the • Digital clock
ignition is switched on. Note: Depending on the audio
With the ignition switched off system fitted, the clock is displayed
(position 0) and the key removed, only while the right-hand button
the display will be automatically is pressed. Displaying the clock
deactivated after approximately permanently and the setting of the
10 minutes. clock is available on the audio
system only. Please see chapter
Multifunction display Quick start, page 9, or the separate
(depending on vehicle variant) manual.
20
Instrumentation
To set the time: Message Centre
• Turn the ignition key to (depending on model variant)
position II.
• Press and hold the right-hand
button until the time display
flashes.
• To advance the time, press the
right-hand button briefly. Each
press advances the time by one
minute.
To advance rapidly, hold the
button pressed.
Tripmeter
The tripmeter can register the
mileage of individual journeys. Gear display
To reset, press and hold the For information, refer to the section
left-hand button beneath the Gear display, page 107 (vehicles
display. with automatic transmission) or
page 116 (vehicles with Durashift
Note: If Sh on appears in the EST).
display instead of the tripmeter, the
shipping mode of the vehicle’s Clock or
electric system is activated. Please the display of the audio
contact your dealer to deactivate system
this mode. Outside air temperature
Odometer Tripmeter
Registers the total mileage of the
vehicle. Odometer
Display warning light
For further information about the
Message Centre, refer to the
chapter Vehicle information
systems, page 22 onwards.
21
Vehicle information systems
MESSAGE CENTRE Note: If SHIP ON appears in the
Switch on the ignition (position II) display, the shipping mode of the
to activate the Message Centre. vehicle’s electric system is
activated. Please contact your
Various systems can be dealer to deactivate this mode.
programmed using the Message
Centre and the multifunction lever Controls
on the steering column.
The Message Centre also provides
warning messages about faults or
system malfunctions. For further
details, refer to the section
Warning/information messages,
page 26. Press the RE/SET button briefly to
toggle between the displays.
For road safety reasons, set Press and hold the RE/SET button
and reset the functions only to reset, to choose a submenu, or to
when the vehicle is stationary. adjust the settings.
If all chimes are activated, a short
Note: The displays depend on the tone will sound to confirm a reset
equipment fitted and therefore or a selection.
certain displays may not appear in
the Message Centre of your
particular vehicle.
The display is activated when the
driver’s door is opened or the
ignition is switched on.
With the ignition switched off
(position 0) and the key removed,
the display will be automatically
deactivated after approximately
10 minutes.
22
Vehicle information systems
23
Vehicle information systems
Main menu
WARNING/INFO
MESSAGES
24
Vehicle information systems
Press the RE/SET button briefly to Refer also to the section Low fuel
toggle between the displays. level warning on page 124.
Press and hold the RE/SET button Average speed
to reset or to choose a sub-menu.
Outside air temperature
25
Vehicle information systems
Warning/information messages
26
Vehicle information systems
Warning See
Message System
light page
98,
red Brakes
99
Automatic
113,
red transmission, Durashift
122
EST
amber/
Engine 123
red
amber/
Driving 124
red
amber Lights 52
amber Lights 52
27
Vehicle information systems
Warning See
Message System
light page
amber Locks 67
amber Locks 67
amber Locks 67
amber Locks 67
amber Locks 67
amber Locks 67
amber Locks 72
28
Vehicle information systems
Warning See
Message System
light page
amber Durashift EST 105-106
amber Lights 48
29
Vehicle information systems
Time setting • To change to the date, press and
Note: On vehicles with a hold the RE/SET button.
compatible audio system, setting
the time is only possible via the
audio system. Please see chapter
Quick start, page 9, or the separate
manual.
The menu is only available when
the vehicle is stationary.
The day flashes.
• Repeat the procedure used for
hours and minutes to set the day,
• Press and hold the RE/SET the month and the year.
button to open the menu.
• To exit the menu after selecting
the year, press and hold the
RE/SET button.
30
Vehicle information systems
Settings menu
Note: For road safety reasons,
changes in the Settings menu can
only be made while the vehicle is
stationary. If this menu or one of its
sub-menus is open when the
vehicle begins to move, the Message If the RE/SET button is not
Centre will automatically exit the pressed for about 7 seconds, this
Settings menu. message is shown to remind you of
the procedure.
31
Vehicle information systems
Setting menu displays
• Press and hold the RE/SET button to enter the Settings menu.
• Press the RE/SET button briefly to toggle between the displays.
• When the corresponding display appears press and hold the RE/SET
button to adjust the settings.
32
Vehicle information systems
Remote control unlocking Radio display
function (depending on the audio system
equipped)
33
Vehicle information systems
Chimes Setting the language
ALL: all chimes are activated. • Press and hold the RE/SET
MINIMAL: the following chimes are button to open the menu.
deactivated:
• RE/SET button press
confirmation.
• Low outside temperature warning
at temperatures under +4 ºC.
• Distance to empty warning at
remaining fuel for 80, 40 and 20 km.
34
Vehicle information systems
Measure units
Imperial measure units (miles, mpg,
mph) are only available with the
language setting ENGLISH MLS.
All other language settings use
metric measure units (km,
l/100 km, km/h).
• When the message like this Settings menu – Exit
appears, press and hold the
RE/SET button to confirm and to
return to the Settings menu.
• Press the RE/SET button briefly
to stay in the Language menu
without changing the setting.
If the button is not pressed for To exit the Settings menu, scroll to
approximately 5 seconds, the this display and press and hold the
display returns to the Settings RE/SET button.
menu. Any changes to the language The Settings menu is left
settings will not be saved. automatically, if the RE/SET button
is not pressed for approximately
20 seconds. Any changes to the
settings will be saved.
35
Climate controls
HEATING, VENTILATION AND Blower
AIR CONDITIONING The blower motor produces the
ventilation air flow and may emit
Outside air noises.
Always keep the air intakes forward
of the front screen free of snow, Side window demisters
leaves etc., to allow the system to When driving these vents provide a
function effectively. constant air stream to the side
windows. This helps to keep the
Recirculated air side windows free of mist and ice.
(if equipped)
When recirculated air is selected, Centre and side vents
only the air currently in the
passenger compartment will be
circulated. Outside air will not enter
the vehicle.
Note: It is not recommended to use
recirculated air for more than
30 minutes as there is no air
exchange and the windows may
mist up.
Fresh air filter/active carbon
filter (if equipped)
The fresh air filter removes most
potentially harmful particles such
as pollen, industrial fallout and road
dust from entering the vehicle’s
interior. The active carbon filter
removes odours.
In an automatic car wash, you The centre and side vents enable
should switch off the ventilation efficient ventilation of the
blower or switch to recirculated air passenger compartment and should
(if equipped) to prevent the filter be used when the cooling of the
collecting wax deposits. compartment is required.
36
Climate controls
The side vents can also be used to The resulting condensation is
remove mist and ice from the side directed to the outside of the
windows. Make sure not to adjust vehicle. It is therefore quite normal
them straight upwards as they can if you notice a small pool of water
also divert the air stream coming underneath the parked vehicle.
out of the side window demisters Note: The air conditioning system
(see also position on the only operates when the
instrument panel overview, page 14 temperature is above +5 ºC, the
onwards). engine is running and the blower is
In winter, after the passenger switched on. Operating the air
compartment has been warmed up, conditioning leads to higher fuel
the air from the centre vents has a consumption. However, also
lower temperature than the air from opening windows for additional
the side vents. According to cooling leads to increased fuel
individual preferences, the centre consumption, especially at higher
vents can be closed in cold weather, road speeds.
or opened for extra fresh air when
heating. General notes on controlling the
climate in the vehicle’s interior
Heating Close all the windows completely.
The heating depends upon the To warm the interior effectively,
coolant temperature and is direct the heated air to the footwell
therefore only effective when the area. In very cold or humid weather,
engine is warm. direct air towards the front screen
and side windows as necessary to
Air conditioning prevent from misting or icing.
(if equipped)
To cool the interior effectively,
The air is directed through the direct the cooled air from the
evaporator/heat exchanger where it centre and side vents towards the
is cooled if the air conditioning is face level.
switched on. In addition, humidity
is extracted from the air to help
keep the windows free of mist.
37
Climate controls
CONTROLS Air distribution control
If your vehicle is equipped with an
Electronic Automatic Climate
Control, please see the
corresponding section, page 41
onwards.
Blower
Blue: Cold
Red: Warm
38
Climate controls
HEATING AND VENTILATION Ventilation
Rapid screen defrosting/
demisting
39
Climate controls
MANUAL AIR CONDITIONING Cooling with outside air
Switching the air conditioning
on/off
40
Climate controls
Reducing air humidity in ELECTRONIC AUTOMATIC
position CLIMATE CONTROL
41
Climate controls
For the system to function properly Setting the temperature
and without restrictions, the side
and centre vents should be fully
open, especially in summer.
The sensor which measures the
interior temperature is located
underneath the climate control
panel in the centre console (see
also position on the instrument
panel overview, page 14 onwards).
Blue button: lower temperature.
The sunload sensor is located on
top of the instrument panel. The Red button: higher temperature.
sensors should not be covered by The temperature can be set
any objects. between 16 °C and 28 °C in steps of
At low outside temperatures, when 0.5 °C using the buttons. In position
the system is in AUTO mode, the LO (below 16 °C) the system will
air stream will be directed to the switch to permanent cooling, in HI
front screen and the side windows (above 28 °C) to permanent
as long as the engine is cold. The heating, and not regulate a stable
heating of the passenger temperature.
compartment will commence as
soon as a minimum air temperature
can be delivered by the engine or
by the auxiliary heater (where
fitted).
42
Climate controls
Setting the blower speed Screen defrosting/demisting
43
Climate controls
Automatic recirculated air Switching the Electronic
control Automatic Climate Control
When the system is in AUTO mode on/off
and the interior and exterior
temperatures are quite hot,
recirculated air is selected
automatically to maximise cooling
of the interior.
Once the selected temperature is
reached, the system will
automatically change to the outside Press OFF to switch off the
air position. The indicator light in Electronic Automatic Climate
the button does not illuminate Control. The settings remain stored.
during the automatic operation. The heating, ventilation and air
conditioning system is switched off
Switching the air conditioning and recirculated air is selected.
on/off Note: This setting is recommended
only when driving with the windows
and/or sunroof open. This ensures
that the automatic function does
not work against the additional air
flow through the windows and/or
sunroof.
Press the A/C button to switch the Press OFF again or AUTO to switch
air conditioning on/off. the system back on. If another
A/C OFF appears in the display button is pressed, the stored
when the air conditioning is settings will be changed accordingly
switched off. when the system is switched on.
A/C appears in the display when
the air conditioning is switched on.
44
Climate controls
HEATED FRONT AND REAR Heated rear screen switch
SCREEN Switch on the ignition first.
Use for quick defrosting or
demisting of the front or rear
screen. It should be switched on
only if necessary.
On vehicles with Electronic
Automatic Climate Control, when
is selected, the heated screens
switch on automatically and switch Press the switch to turn on or off.
off after a short time. The light in the switch indicates
operation.
Heated front screen switch Electrically operated door mirrors
The system operates only when the also have a heating element to clear
engine is running. the glass. This system operates
when the heated rear screen is
switched on.
The heating system switches off
automatically after a short period.
AUXILIARY HEATER
(vehicles with a diesel engine −
Press the switch to turn on or off. depending on country)
The light in the switch indicates The auxiliary heater aids in
operation. warming the interior compartment
The heating system switches off and also the engine on vehicles with
automatically after 4 minutes. diesel engines. It delivers warm air
quickly after engine start, even if
the engine is not warmed up yet. It
is automatically switched on or off
depending upon the outside
temperature, the coolant
temperature and the alternator
load.
45
Lights
EXTERIOR LIGHTS AUTO Autolamps
An audible signal will be heard if (depending on model variant)
the driver’s door is opened with the
exterior lights switched on and the
ignition switched off.
Exterior lights switch
46
Lights
In AUTO mode, if the headlights go Headlight indicator light
off automatically with main beam
activated, the next time the
Autolamp feature turns on the
headlights main beam will still be
on. Dipped beam may be selected The headlight indicator light
by pulling the multifunction lever illuminates when the headlights or
towards the steering wheel. Refer the side and tail lights are on.
to the section Multifunction lever, Front fog lights
page 51 onwards.
Note: It is not possible to switch on
the front or rear fog lights when the
exterior lights control is set to
AUTO. To switch on the front
and/or rear fog lights, turn on the
headlights by setting the control to
position .
47
Lights
Front and rear fog lights Home safe lights
Within the first 10 minutes after the
ignition is switched off the
headlights can be switched on.
They will then be switched off
automatically after a period of time.
On vehicles with Autolamps,
48
Lights
On vehicles without Autolamps, The lights will switch off
automatically:
• as soon as the exterior lights
switch is turned to any position,
• as soon as the ignition is switched
on (position II),
• as soon as any door or the tailgate
is unlocked using the remote
control,
• after 3 minutes, if any door or the
tailgate is open, or
turn the exterior lights switch • after 30 seconds if all doors and
from the position to the tailgate are closed.
position and back to
position within 2 seconds, or Welcome lights
turn the exterior lights switch Depending on model variant, the
from the position to side and tail lights are switched on
position and back to automatically when the vehicle is
position within 2 seconds. unlocked using the radio frequency
remote control.
The lights switch off automatically
• after 25 seconds,
• or 5 seconds after all opened
In addition, on vehicles with a doors are closed,
Message Centre, this message will • or as soon as the ignition is
appear in the display and the switched on or the vehicle is
display warning light illuminates locked.
amber.
49
Lights
Headlight levelling control
The level of the headlight beams
can be adjusted according to the
vehicle load.
50
Lights
Multifunction lever • Lane change indicators
The following functions will operate function
only with the ignition switched on. If the lever is tapped up or down,
the direction indicators will flash
Direction indicator three times.
To activate/deactivate this feature,
see section Settings menu, page 31
onwards.
• Hazards on heavy braking
If the brakes are applied abruptly
(e. g. in case of an emergency
braking), the hazard lights will
automatically flash for a minimum
of three times.
For further information, see section
Hazards on heavy braking
feature, page 100.
51
Lights
Direction indicator light Main/dipped beam
52
Lights
INTERIOR LIGHTS Reading lights
Reading lights
(depending on model variant)
Off
Door contact On
On Off
On some models, with the switch in
the position, the interior lights
will stay on for a while after the
doors are shut. They go off
immediately after the ignition is
turned on.
When parking your vehicle with the
doors open for a long period of
time, the interior lights and the
luggage compartment light are
switched off automatically after
10 minutes. If the interior lights are
left in the position, they will be
switched off after 30 minutes.
To switch the lights back on, switch
on the ignition (position II) for a
short time, open a door or press the
button of the radio frequency
remote control.
53
Driver controls
STEERING WHEEL HORN
ADJUSTMENT
Never adjust the steering
wheel when the vehicle is
moving.
54
Driver controls
SCREEN WIPER/WASHER To set the intermittent wipe
CONTROLS interval:
The following functions will operate
only with the ignition switched on.
Front screen
Lever positions:
Select wipe interval with rotary
switch:
1 = Short time interval
6 = Extended time interval
Autowipers
(depending on model variant)
When Autowipers is selected
(position ), the wipers will cycle
once regardless of whether the
front screen is wet or dry.
Thereafter, or when the ignition is
Single wipe switched on with the wiper lever
Intermittent wiping or already in position , the wipers
Autowipers will not cycle until water is
(depending on model variant) detected on the front screen.
Normal wiping The rain sensor will continuously
High speed wiping measure the amount of water on
the front screen and adjust the
speed of the front wipers
automatically (single wipe,
intermittent, normal or high speed
wiping).
55
Driver controls
56
Driver controls
Rear screen Washer
Wiping
57
Driver controls
AUDIO REMOTE CONTROL • In CD mode, it will select the
Select radio, CD or cassette mode next or the previous track.
on the radio.
Mode
The following functions can be
operated with the remote control:
Volume
58
Driver controls
MIRRORS Manually adjustable outside
rear-view mirrors
Interior rear-view mirror
59
Driver controls
Electrically operated and heated Electrically operated folding
outside rear-view mirrors function
The outside rear-view mirrors are (depending on model variant)
heated when the heated rear screen
is switched on.
60
Driver controls
FRONT POWER WINDOWS To open/close the windows
Before operating power The front windows can be operated
windows you should verify with switches located on the door
they are free of obstructions and trim of the driver’s door. The
ensure that children and/or pets windows open/close when the
are not in the proximity of switch is pressed. The front
window openings. Failure to do so passenger’s window can also be
could result in serious personal operated with a switch on the door
injury. It is the primary trim of the passenger’s door.
responsibility of the supervising The windows open/close only when
adults never to leave a child a button is pressed.
unattended in a vehicle and never
to leave the keys in an
unattended vehicle.
61
Driver controls
OTHER CONTROLS
Sunroof
Always push the handle back into
its recess after use.
To open the sunroof
62
Driver controls
Cigar lighter/power point When connecting appliances, use
only specified connectors from the
Ford Accessory range or connectors
suitable for use with SAE standard
sockets.
Front ashtray
63
Locks (security)
KEYS Key with radio frequency remote
control
To ensure a trouble-free
data exchange between the
vehicle and key, do not shield the
keys with any metal objects.
64
Locks (security)
65
Locks (security)
Rear door childproof safety Luggage compartment
locks
Opening the tailgate
When the childproof safety The luggage compartment light will
lock is activated, the door come on automatically. If the
can only be opened from outside. luggage compartment remains open
with the ignition switched off, the
light will be switched off
automatically after 10 minutes.
1. By pressing the Remote luggage
compartment release on the
instrument panel.
66
Locks (security)
Closing the tailgate
67
Locks (security)
CENTRAL DOOR LOCKING To lock the rear doors and (vehicles
SYSTEM with remote control) the front
passenger’s door individually, press
the door handle and close the door
when leaving the vehicle.
The luggage compartment remains
locked when the system is
deactivated.
Central locking with double
locking system
68
Locks (security)
Unlocking the vehicle Note: After 22 days the remote
locking system will shut down to
save the battery. It will be
reactivated when the doors are
unlocked with the key.
Automatic relocking
Note: To prevent the vehicle being
left unlocked inadvertently, central
locking and the anti-theft alarm
system will be reactivated
automatically 45 seconds after the
button is pressed if the following
occurs during this period:
• No door is opened.
• The luggage compartment is not
oppened.
• The ignition is not switched on.
With the key: Turn the key in the
driver’s or front passenger’s door to If a failure occurs in the
position . vehicle’s electrical system,
the front doors and the tailgate
can still be individually unlocked
with a key.
69
Locks (security)
Reprogramming the unlocking Locking the vehicle
function To activate central locking and arm
You can change the unlocking the anti-theft alarm system (if
function so that pressing the equipped):
button once deactivates the double
locking and the anti-theft alarm
system and unlocks only the
driver’s door. Pressing the button
again within 3 seconds also unlocks
the passenger’s doors.
To re-programme the function, see
section Settings menu, page 31
onwards, if a message centre is
equipped.
70
Locks (security)
To activate double locking and arm Programming additional radio
the anti-theft alarm system (if frequency remote controls
equipped): A maximum of four radio frequency
remote controls can be
programmed (including the ones
delivered with the vehicle).
Left-hand door.
Right-hand door.
1. To programme new radio
With the key: Turn the key in the frequency remote controls turn the
driver’s or front passenger’s door to ignition key from position 0 to
position and then to position position II four times within six
within two seconds. seconds.
2. Switch off the ignition. A tone
sounds to indicate that it is now
possible to programme new radio
frequency remote controls for
10 seconds.
71
Locks (security)
72
Locks (security)
ENGINE IMMOBILISATION Automatic arming
SYSTEM
The engine immobilisation system
is a theft protection feature which
prevents the engine from being
started with an incorrectly coded
key.
Coded keys The system is armed after switching
off the ignition. The Engine
immobilisation system indicator
light in the instrument cluster will
flash.
Automatic disarming
Switching on the ignition disarms
the system if the correct code is
recognised. The indicator light in
the instrument cluster illuminates
for approximately 3 seconds and
Your vehicle is supplied with coded then extinguishes.
keys. If the indicator light stays
Replacement keys must be recoded illuminated or begins to flash
together with your other keys. rapidly, the system remains armed
and the engine does not start.
Remove the key and try again.
If the engine does not start, a
system malfunction has occurred.
Have the system checked by an
expert immediately.
73
Locks (security)
Key coding 5. If an uncoded key is now
A maximum of eight keys inserted in the ignition switch and
(including the ones delivered with turned to position II within
the vehicle) can be coded using two 20 seconds, this key is coded to the
other keys previously coded for system.
your vehicle. 6. After the coding process is
Complete each of the following completed remove the key from the
steps within 10 seconds. ignition switch.
74
Locks (security)
Coding erasure 8. If the ignition is switched off
With two keys coded for your during these 5 seconds, the erasure
vehicle you can make all the other process is terminated and no key is
coded keys unusable, e.g. after loss. erased.
Complete each of the following 9. If the erasure process is
steps within 10 seconds. completed, all the other keys, apart
Carry out the first four steps under from the two used for erasure, can
Key coding, then continue as no longer be used unless recoded.
follows: Additional keys can now be coded.
75
Locks (security)
ANTI-THEFT ALARM SYSTEM Alarm
The system is armed as soon as the The alarm sounds for 30 seconds if
vehicle is locked and acts as a an unauthorised person opens a
deterrent to unauthorised persons door, the luggage compartment or
who attempt to open the doors, the bonnet. The hazard flasher
bonnet or luggage compartment. lights will flash for 5 minutes.
Any attempt to start the engine
Automatic arming delay without a valid key sounds the
Up to 20 seconds after arming the alarm again.
anti-theft alarm system, it is still
possible to open the vehicle again To switch off
without triggering the alarm. After The anti-theft alarm system can be
that, the anti-theft alarm system disarmed at any time – even when
will monitor all doors, the bonnet the alarm is sounding – by
and the tailgate, provided that they unlocking either of the front doors
are closed. If a door, the bonnet or with the key or with the remote
the tailgate is closed later, the control.
system will monitor it after
20 seconds. The anti-theft alarm system on the
tailgate is disarmed when the
luggage compartment is unlocked
with a key.
After closure, the alarm is once
again armed.
76
Seating and safety restraints
SEATS Do not use any accessory
seat covers that are not
Sitting in the correct position specifically designed for seats
with side airbags. These seat
covers must be fitted by properly
trained technicians.
77
Seating and safety restraints
Adjusting the height of the Armrest
driver’s seat
78
Seating and safety restraints
Fold flat front passenger seat Do not place objects on the
table surface when driving
as these could become projectiles
in the event of an accident or
heavy braking.
Driver’s seat
Front passenger’s seat
Only children up to 18 kg may
travel on the rear seat when the
passenger seat is folded flat.
79
Seating and safety restraints
The red mark on the side of the Rear head restraints
switch indicates that the heated
seat is on.
The maximum temperature is
reached after five or six minutes. It
is regulated thermostatically.
When selected the heating will
operate when the ignition switch is
in position II.
Head restraints
Front head restraints
To raise, pull the head restraint up
until it engages properly.
To lower, press the locking button
and push the head restraint down.
Always have the rear head
restraint raised when the
rear seat is occupied by a
passenger or a child restraint.
80
Seating and safety restraints
Folding the rear seatback Returning the seatback to its
forwards upright position
Lower the rear head restraints.
81
Seating and safety restraints
Folding the seat cushion and SEAT BELTS
seatback forwards
• Use seat belts at all times.
• Never use a seat belt for more
than one person.
• Avoid wearing thick clothing.
• The seat belts should fit tightly
around the body.
82
Seating and safety restraints
To release the belt, press the red Adjusting the height of the front
button on the buckle and let the seat belts
belt rewind completely and
smoothly.
83
Seating and safety restraints
Pregnant women The lap strap should be fitted
comfortably across the hips, low
beneath the pregnant abdomen.
The diagonal part of the seat belt
should be placed between the
breasts, and worn above and to the
side of the pregnant abdomen.
Always wear seat belts without
slack or twists. For optimum
protection, the seat belts should fit
tightly around the body. Do not
recline the front seats excessively,
as the belts provide maximum
protection when the seats are in the
near upright position.
Never wear just the lap
strap of a lap/shoulder
diagonal seat belt and never sit on
the lap strap using just the
shoulder strap. Both of these
actions are extremely dangerous
and may increase your risk of
serious injury.
84
Seating and safety restraints
Seat belt pretensioner The restraint system, with belt
pretensioner in the front seats,
The belt pretensioners must helps to reduce the risk of serious
not be removed. If the injury in a major frontal impact.
pretensioners deployed during an During a serious crash the seat
accident, they must be replaced. belts are pretensioned to help
Have the pretensioners serviced reduce slack in the belt. The safety
and disposed of by specially belt pretensioner is a device which
trained personnel only. removes excess webbing from the
safety belt system. When the safety
belt pretensioner deploys, webbing
from the lap and shoulder belt is
tightened.
The belt pretensioner is not
triggered in any side, rear or minor
frontal collisions. For further details
refer to section Airbag, page 87
onwards.
Driver’s seat
Front passenger’s seat
85
Seating and safety restraints
Care of seat belts
86
Seating and safety restraints
87
Seating and safety restraints
Front airbags Do not modify the front of
The seat and back must be set the vehicle in any way as
correctly for the airbags to be this can adversely affect airbag
optimally effective. Refer to section deployment.
Sitting in the correct position,
page 77.
This is the ideal seating position for
the driver and front passenger and
helps reduce the risk of injury from
sitting too close to an inflating
airbag.
88
Seating and safety restraints
During minor collisions as well Side airbags
as overturns and rear or side
collisions, the front airbag
system will not be activated.
Always keep the areas in
front of the airbags free.
Never affix anything to or over
these areas.
89
Seating and safety restraints
Front and rear curtain airbags
90
Seating and safety restraints
Airbag/seat belt pretensioner
warning light
91
Seating and safety restraints
ON
After removing the child restraint
from the front, make sure that the
key switch is turned to the ON
position .
To ensure the adult
When the ignition is switched on restraint system performs
(position II), check that the airbag as intended, make sure the airbag
deactivation light is illuminated. is ON.
92
Seating and safety restraints
CHILD RESTRAINTS Extreme Hazard! Do not use
Together with the adult seat belt, a rearward facing child
these restraints help provide restraint on a seat protected by
maximum security for children. an operational airbag in front of
Children of height 150 cm or under it!
or 12 years or under should be There is a risk of death or serious
secured in special restraints for injury when the airbag deploys.
children, such as baby seats, child
safety seats or booster seats and
cushions in the rear seat. Size and Whenever installing a child seat/
age limits for mandatory use of restraint, always read and follow
child restraints vary between the manufacturer’s instructions.
individual countries. There is a risk of death or
Such equipment must be suitable serious injury when the
and government approved manufacturer’s instructions are
(depending on country). not followed properly or when the
child restraint is modified in any
way.
93
Seating and safety restraints
Placement of child restraints The following table advises on the
suitability of child restraint fitment
If your Ford vehicle is
locations.
equipped with a front
passenger airbag, it is
recommended that children of
height 150 cm or under or aged
12 years and under should only be
properly restrained in the rear
seat. Rearward facing child
restraints must NEVER be used
in the front passenger seat
protected by an OPERATIONAL
front passenger airbag.
X = Seat position not suitable for To use a child restraint in the front,
children in this mass/age group. make sure that the passenger
U = Seat position suitable for airbag deactivation key switch is
universal" category restraints turned to the OFF position (see
approved for use in this mass/age page 91 onwards).
group.
U1 = Seat position suitable for
universal" category restraints but
Ford recommends that children
should be secured in an appropriate
child restraint in the rear seats.
94
Seating and safety restraints
95
Seating and safety restraints
• Child safety seat • Booster seat/booster cushion
Booster seat
Children weighing between 13 and Booster cushion
18 kg (approximately eighteen
months to four years old) should be Children weighing more than 15 kg
carried properly restrained in child and under 150 cm should use a
safety seats (Group I) in the rear booster seat or booster cushion.
seat. Ford recommends using booster
seats that combine a booster
cushion and a back rest into one
seat for children between 15 kg and
25 kg. The raised seating position
ensures that the adult seat belt can
be correctly guided over the centre
of the shoulder instead of along the
neck, the lap belt lying tightly
across the hips instead of the
stomach. Make sure that your child
sits in an upright position.
96
Seating and safety restraints
Note: You should never use a
• If the vehicle has been involved in booster seat or cushion with
an accident, have the child safety only a lap belt.
seat checked by an expert as it Never put the shoulder belt under
might be damaged. a child’s arm or behind the back.
• When the child seat is not in use
but inside the vehicle, secure it Never use pillows, books, or
with the seat belt. towels to boost a child.
• Do not leave children unattended
in the child safety seat or in the
vehicle.
• When installing a child
seat/restraint with the seat belt,
always ensure belts fit without slack
or twists.
97
Driving
BRAKES Brake system warning
Dual circuit braking system
98
Driving
Anti-lock Braking System (ABS) Brake system and ABS warning
lights
99
Driving
Emergency Brake Assist Handbrake
(depending on model variant)
The Emergency Brake Assist is able
to detect an emergency braking
situation by measuring the rate at
which the brake pedal is applied. It
automatically provides maximum
braking efficiency as long as the
pedal is applied. This can reduce • Press the foot brake pedal firmly.
stopping distances in critical • Pull the handbrake lever up
situations. smartly to its fullest extent.
The Emergency Brake • Do not press the release button
Assist is an additional while pulling the lever up.
system which is not intended to
relieve the driver of his • If your vehicle is parked on a hill
responsibility for exercising due and facing uphill, select first gear
care and attention when driving. and turn the steering wheel away
from the kerb.
• If your vehicle is parked on a hill
Hazards on heavy braking and facing downhill, select reverse
feature gear and turn the steering wheel
(depending on country) towards the kerb.
At a vehicle speed of 96 km/h or
more and if the brakes are applied Vehicles with an automatic
abruptly (e. g. in case of an transmission should always
emergency braking), the hazard be left with the selector lever in
lights will automatically flash for a position P.
minimum of three times.
To release the handbrake, press the
When the vehicle moves off again or brake pedal firmly, pull the lever up
if the hazard flasher switch is slightly, depress the release button
pressed, the hazard lights are and push the lever down.
switched off. The function is
available again, when the vehicle’s
speed reaches 96 km/h or more.
To activate/deactivate this feature,
see section Settings menu, page 31
onwards.
100
Driving
ELECTRONIC STABILITY The system also supports stability
PROGRAM (ESP) by counteracting the tendency of
the vehicle to swerve away from the
Drivers should never take intended path. This is performed by
unnecessary risks even braking individual wheels and/or
though the ESP system offers reducing engine torque as needed.
inherently safer driving potential.
Principle of operation
101
Driving
Switching off the ESP STEERING COLUMN LOCK/
IGNITION SWITCH
102
Driving
GENERAL POINTS ON STARTING THE ENGINE
STARTING
The starter will not operate for Vehicles with a petrol engine
longer than 30 seconds during each Cold/hot engine
start cycle. Release the ignition key • Depress the clutch pedal fully and
as soon as the engine has started. start the engine without touching
If the engine has not started, return the accelerator.
the ignition key to position 0 and
repeat the starting procedure. At temperatures below
-20 ºC, turn the ignition key
If the engine does not start, to position II for at least one
refer to the instructions second before starting the engine.
regarding the fuel injection This ensures that maximum fuel
system shut-off switch on pressure is established.
page 139.
• If the engine does not start within
Engine speed limiter 15 seconds, wait for a short period
and repeat the procedure.
The engine speed is limited
electronically to protect the engine. • If the engine does not start after
three attempts, wait 10 seconds
and follow the Flooded engine
procedure.
• If starting difficulty is
experienced at temperatures below
-25 ºC, depress the accelerator
pedal 1/4 to 1/2 of its travel to assist
starting.
Flooded engine
• Depress the clutch pedal fully.
• Slowly depress the accelerator
fully, hold it in this position and
start the engine.
• If the engine does not start repeat
the Cold/hot engine procedure.
103
Driving
Vehicles with a diesel engine Switching off the engine
If the vehicle run out of fuel, see
section Diesel low fuel safety
mode, page 124.
Cold/hot engine
• Depress the clutch pedal without
touching the accelerator.
• Turn the key to position II.
104
Driving
Vehicles with automatic Vehicles with Durashift EST
transmission
The engine can be started only with
the selector lever in position P.
If necessary, it can also be started
with the lever in position N.
105
Driving
If the brake pedal is not pressed the MANUAL TRANSMISSION
gear will not be released, the
display will flash and the vehicle Do not apply any undue
will not start. lateral force to the gear
lever when changing from 5th to
4th gear as this could lead to the
inadvertent selection of 2nd gear.
106
Driving
AUTOMATIC TRANSMISSION Selector lever positions
The four-speed automatic Apply the handbrake or
transmission is electronically depress the footbrake
controlled. before selecting a gear. Failure to
do so could result in the vehicle
Selector lever
pulling away when you have
engaged a gear.
107
Driving
P = Park R = Reverse
In this position, the transmission is This position should be selected
locked. only when the vehicle is stationary
and the engine is idling.
This position should be
selected only when the N = Neutral
vehicle is stationary. In this position, no power is
transmitted to the drive wheels.
Whenever you leave the In this position, you have to
vehicle, make sure that the depress the brake pedal or
selector lever is securely latched apply the handbrake to prevent
in P, always apply the handbrake the vehicle from moving.
fully and turn off the ignition.
D = Drive
A warning signal will sound
if the drivers door is opened When stationary, this
when position P is not selected. position should only be
selected when the engine is
idling.
108
Driving
2 = Gear 2
The automatic transmission
remains permanently in 2nd gear.
This position should be selected on
severe downhill gradients.
It can also be used to avoid
frequent shifting between 1st and
2nd gears in slow moving traffic or
to help when moving off on slippery
or icy surfaces.
For driving on long uphill gradients,
see section Uphill mode, page 112. Depress the button located under
1 = Gear 1 the grip at the side of the selector
lever to switch the overdrive off and
The automatic transmission
on. The overdrive can be switched
remains permanently in 1st gear.
off and on while driving.
This position should be selected on
When the ignition is switched on
extreme downhill gradients.
again, overdrive is automatically
For driving on long uphill gradients, switched on.
see section Uphill mode, page 112.
Overdrive indicator light
Overdrive
The 4th gear is designed as an
overdrive.
Switching off the overdrive can help
to increase the engine braking The indicator light in the
effect for enhanced control when instrument cluster illuminates when
driving on downhill gradients or if the overdrive is switched off.
the transmission is frequently
shifting between 4th and 3rd gear.
With the overdrive switched off, the
transmission will shift only between
gears 1 – 3.
109
Driving
Driving with automatic Manual gear changes
transmission
• Moving off
Moving off
Select position 1, release the
With the engine idling and the handbrake and depress the
brake pedal depressed, move the accelerator pedal. Move the
selector lever to one of the driving selector lever to position 2 and D as
positions. Release the brakes. The the road speed increases.
vehicle will start to move slowly in
the selected direction. Depress the • Changing down
accelerator pedal to increase speed.
If the transmission is in 4th gear
When stationary, only move and the overdrive is switched off
the selector lever to one of the transmission will change down
the driving positions when the to 3rd gear if the vehicle speed is
engine is idling. below 165 km/h. See also section
Overdrive, page 109.
If the selector lever is moved from
• Moving off in sand, mud or position D to position 2 while
snow driving, the automatic transmission
If the driving wheels are stuck, try will change down to 2nd gear if the
to rock the vehicle free by driving vehicle speed is below 85 km/h and
forwards and backwards. To do this, will then remain in this gear. If the
move the selector lever alternately selector lever is moved to position 1
to D and R and depress the while driving, the transmission will
accelerator as little as possible. change down to 1st gear if the
vehicle speed is below 45 km/h and
To increase the effect, move the
will then remain in this gear.
selector lever to R while the vehicle
is still moving forward and vice Stopping
versa. Release the accelerator pedal and
To avoid excessive wear on the depress the footbrake. Leave the
transmission when shifting between selector lever where it is. To move
forward and reverse (rocking) keep off again release the footbrake.
the engine speed as low as possible. Select position N if stationary for
Selecting position 2 may assist longer periods of time.
driving-off on icy or snowy road
surfaces.
110
Driving
Emergency park position Drive modes
release lever
Downshift
This enables the selector lever to be
moved out of the park position P in When activated, this mode provides
the event of a discharged battery or maximum vehicle performance
electrical failure. when overtaking or, in conjunction
with the Uphill mode, driving up
steep gradients.
With the selector lever in position
D, the transmission will select the
appropriate gear according to the
position of the accelerator pedal.
111
Driving
Kickdown Uphill mode
When activated, this mode provides Always use selector lever position D
maximum possible acceleration for driving on uphill gradients. The
when overtaking or, in conjunction automatic transmission detects
with the Uphill mode, driving up uphill gradients and automatically
steep gradients. selects the most appropriate gear.
Avoid using selector lever positions
1 and 2 when driving on long uphill
gradients as under some
circumstances this can cause the
transmission operating temperature
to rise above normal limits and
enter the Hot mode. See section
With the selector lever in position Hot mode, page 113.
D, depress the accelerator pedal
fully beyond its resistance point Downhill mode
and hold it down. Supports your braking manoeuvre
The Kickdown mode is activated while driving downhill.
and the transmission will select the When appropriate, the transmission
appropriate gear for maximum shifts down from 4th to 3rd gear to
possible acceleration. In some increase engine braking when the
situations, this gear may already be brakes are applied during downhill
selected. driving.
With the Kickdown mode activated, Cold mode
the transmission will not shift into
the next higher gear until the In order to increase the
engine speed approaches its upper transmission’s efficiency and reduce
limit. wear and tear, 4th gear will not be
selected until the transmission has
Keep the pedal pressed fully reached normal operating
beyond the resistance point to keep temperature.
the Kickdown mode activated for as
long as maximum acceleration is
required.
The transmission will return to its
normal operating mode as soon as
the accelerator pedal is released
and returns to any position before
the resistance point.
112
Driving
Hot mode Emergency mode
When high transmission If a malfunction occurs in the
temperatures are detected, this transmission, this mode may be
mode is activated to help prevent activated. This will result in unusual
damage to the transmission. vehicle behaviour.
113
Driving
114
Driving
DURASHIFT EST Creeping
The Durashift EST is an automated If D or R are engaged with
five-speed manual transmission. the engine running and the
The clutch and the gear selection footbrake is then released, on a
are operated automatically. flat surface the vehicle will slowly
move off on its own (creep
Selector lever
function).
115
Driving
Gear display Selector lever positions
Apply the handbrake or
depress the footbrake
before selecting a gear. Failure to
do so could result in the vehicle
pulling away when you have
The display in the instrument engaged a gear.
cluster shows the gear position
currently selected.
N = Neutral
Auto is displayed when automated
mode is selected.
116
Driving
R = Reverse D = Drive (automated mode)
Select this position only
when the vehicle is
stationary and the engine is
idling.
117
Driving
When in automated mode and +/– = Manual mode
selector positions +, – or A are used
manual mode will be selected. The Do not hold the shift lever
display will show the current permanently in A, + or –.
engaged gear.
A = Mode change
118
Driving
Driving with Durashift EST • Moving away in sand, mud or
snow
Moving off
If it becomes necessary to rock the
vehicle to free it from snow, mud
etc. move the selector lever
between D and R repeatedly whilst
applying light pressure to the
accelerator pedal.
Do not race the engine and
avoid sudden acceleration.
To protect the system the starting
off aid is disabled at very high
clutch temperatures.
119
Driving
Downshift (Kickdown) Stopping
(Automated mode only)
When stopping or waiting
on a gradient always apply
the handbrake. To prevent
overheating of the clutch do not
increase the engine revolutions.
120
Driving
Parking with Durashift EST Driving on inclines
Before leaving the vehicle • Hill starts
always apply the
Do not hold the vehicle on a hill or
handbrake. If the engine is left
against a kerb using accelerator
running move the selector lever
pedal.
to N.
If the clutch becomes overheated a
warning will be activated. The
To park in gear the ignition should Transmission/Engine systems fault
be on and the brake pedal warning light illuminates (see also
depressed. The last gear engaged page 122) and the clutch will pulse.
will be retained. Normal operation will return when
When the selector lever is in the clutch has cooled down.
position N no gear will be retained
and the vehicle is parked in • Automated mode
Neutral. When driving, a higher gear will not
When the ignition is switched off be selected until a reasonably high
the transmission no longer engine speed has been achieved.
responds to movement of the shift
lever. • Manual mode
To utilise engine braking select a
lower gear when driving down hill.
Adaptive Shift Programmes
Adaptive programmes automatically
adapt gear shifting to suit the
driving conditions such as if the
vehicle is towing a caravan/trailer,
has a high payload or is being
driven on steep inclines.
121
Driving
WARNING LIGHTS AND
MESSAGES
Transmission/Engine systems
fault warning In addition, on vehicles with a
Message Centre, this message will
A malfunction of the engine and
appear in the display.
powertrain related systems is
indicated by the following: The display warning light
illuminates amber (point 1) or red
(point 2).
Vehicles with Durashift EST
1. The Transmission/Engine
systems fault warning light
illuminates permanently when
driving.
In addition this message may
The vehicle can still be driven. A appear in the display and the
minor reduction in performance display warning light illuminates
may occur such as reduced power red.
and/or acceleration.
Refer to point 1.
Have your vehicle checked by an
expert as soon as possible. Vehicles with automatic
2. If the Transmission/Engine transmission
systems fault warning light flashes See also sections Hot mode and
when driving, stop the vehicle as Emergency mode, page 113
soon as safely possible and switch onwards.
off the engine immediately.
Have the engine checked by an
expert immediately.
122
Driving
Engine warning light Power steering failure
(vehicles with 1.6 l Duratorq-TDCi
engine)
123
Driving
Frost warning REFUELLING
Low fuel level warning light
124
Driving
Fuel filler flap Filling up
Refer also to the section Fuel,
page 172.
To avoid fuel spillage that
could be hazardous to other
road users, always stop refuelling
after the fuel nozzle stops the
second time. Additional fuel will
fill the expansion space in the fuel
tank which could lead to fuel
overflowing.
To unlock the filler flap, turn the The fuel system is under
key clockwise and open. Turn the pressure. There is a risk of
cap anticlockwise and remove. injury if the fuel system is leaking.
Do not use any kind of flames or
When the filler cap is removed, a heat near the fuel system.
hissing noise may be heard. This is
normal and should be disregarded.
To close, turn the cap clockwise Incorrect fuel
until it engages. If you fill your vehicle with
incorrect fuel or additives,
do not attempt to start the
engine. This may lead to engine
damage.
125
Driving
DRIVING WITH A CATALYTIC VEHICLE LOADING
CONVERTER
• Avoid running out of fuel. Transporting luggage
• Avoid unnecessarily long engine
cranking periods.
• Do not run the engine with a
disconnected spark plug.
• Do not push-start or tow-start the
vehicle; use jump leads.
• Never switch off the ignition
while driving.
Parking
It is important to avoid
parking, idling or operating
the vehicle on dry leaves or dry
grass. Even when the engine is
switched off, the exhaust will
continue to radiate a considerable Luggage and other loads
amount of heat for a short period should be placed as low and
creating a potential fire hazard. as far forward as possible within
the luggage compartment. Driving
with the tailgate/rear door open is
potentially dangerous as exhaust
fumes may be drawn into the
vehicle’s interior.
126
Driving
Luggage cover
Do not place objects on the
luggage cover.
Removal
127
Driving
Luggage net Never drive with the front
storage compartment lid
open. This will obscure your
vision out of the front screen.
Before setting off, always ensure
that the lid is securely engaged.
Storage compartment
128
Driving
Glove compartment Under-seat storage
The storage box is located under
the front passenger seat.
Card holder
Coin holders
Pen/pencil clip
129
Driving
Map pockets Storage pockets
(depending on model variant)
Driver’s seat
Rear seats
130
Driving
Installing the activity console
(depending on model variant)
The activity console can be
installed in the centre of the rear
seat after removing the seat
cushion.
131
Driving
132
Driving
TRAILER TOWING Detachable towball arm
If your vehicle has a
detachable towball arm,
remove and reinstall it regularly
to keep the locking mechanism
working smoothly.
133
Driving
Unlocking the towball arm Inserting the towball arm
mechanism
Special care should be
taken when fitting the
towball arm, as the safety of the
vehicle and the trailer depends on
this.
134
Driving
Driving with a trailer
Before starting your journey, ensure
the towball arm is properly locked.
Check:
135
Driving
Removing the towball arm Maintenance
Keep the system clean. Periodically
lubricate the lock with graphite.
Remove the towball arm
and protect the seat with
the plug before steam cleaning
your vehicle.
136
Driving
ULTRASONIC PARK DISTANCE Have the system checked by an
SENSOR expert.
The park distance sensor is
an auxiliary system which is
not intended to relieve the driver
of his responsibility for exercising
due care and attention when
reversing. In particular, some
objects close to the vehicle
(approx. 30 cm) and above or
below the sensors may not be
detected by the park distance
sensor and cause damage to the
vehicle. Ultrasonic waves, heavy
rain and/or conditions causing
disruptive reflections may lead to
objects not being detected by the
sensors. In addition, objects
which absorb ultrasonic waves
may not always be detected due
to their unfavourable surface
characteristics.
137
Roadside emergencies
HAZARD FLASHER SWITCH LIMITED OPERATION
STRATEGY PROGRAMME
138
Roadside emergencies
FUEL INJECTION SYSTEM The button under the yellow cap
SHUT-OFF SWITCH will be raised when the switch is
(vehicles with a petrol engine) activated.
The fuel supply may be cut off as a
result of an accident or sudden Resetting the switch
vibrations (e.g. collision when Do not reset the fuel pump
parking). shut-off switch if you see or
smell leaking fuel.
139
Roadside emergencies
FUSES
Switch off the ignition and
all the electrical equipment
before changing a fuse.
140
Roadside emergencies
Fuse chart label Symbols in the fuse boxes
The fuse chart label shows
rectangles representing a fuse. The Symbol Definition
following information is shown in
the rectangles:
See Owner’s Handbook
Airbag
ABS
Dipped beam
Number of the fuse (F).
Symbol of the function, see
table on the following page.
Main beam
L = left-hand side,
R = right-hand side.
Ampere rating of the fuse.
Fog lights
Light switch
Front wiper
141
Roadside emergencies
Electrically operated
Daytime running light
outside rear-view
(Scandinavia only)
mirrors
Automatic
Front power windows transmission/
Durashift EST
Engine management
Electrically operated
(Diesel only) or
sunroof (not used)
catalytic converter
142
Roadside emergencies
Hazard flasher,
Audio, diagnostic plug
direction indicator
Engine management
Ignition
or electronic module
Auxiliary heater/
Diesel glow plug/
Durashift EST
Injector pump relay/
Fuel fired heater
Instrument cluster,
battery saver, number
Reversing light
plate light, generic
electronic module
143
Roadside emergencies
BULB REPLACEMENT Removing the light assembly
Always switch off lights and ignition 1. Open the bonnet.
before replacing any bulb.
Never touch the glass of the bulbs.
Fit only bulbs having a UV filter.
Always replace a faulty bulb with a
new one of the same type. After
replacing a bulb, check that the
lights operate correctly.
Have the headlight
alignment checked after
each replacement of a bulb.
144
Roadside emergencies
145
Roadside emergencies
• Headlights – main/dipped • Side lights
beam 5 watt wedge base bulb
H4, 55/60 watt halogen bulb
146
Roadside emergencies
Side repeater indicator Front fog lights
5 watt wedge base bulb H11, 55 watt halogen bulb
147
Roadside emergencies
Rear lights
1. Open the tailgate.
Brake/tail light
21/5 watt
Direction indicator
21 watt (orange bulb)
Reversing light
21 watt
Rear fog light
2. From inside the luggage 21 watt
compartment, lift the flap in the
trim panel and remove the wing nut 5. Turn the bulb anticlockwise
on the rear of the light assembly. under slight pressure, and remove
it.
3. Remove the screws on the front
of the rear light assembly and 6. Replace the bulb.
carefully pull it out. Install in the reverse order.
4. Open the 6 clips and remove the
entire bulb holder.
148
Roadside emergencies
High mounted central brake Interior lights
light 10 watt festoon bulb
16 watt wedge base bulb
149
Roadside emergencies
Reading lights Luggage compartment light
5 watt spherical bulb 5 watt wedge base bulb
150
Roadside emergencies
CHANGING A WHEEL If your vehicle is fitted with
directional tyres, make sure
that the arrows on the tyres point
in the direction of rotation when
the vehicle is moving forwards.
The arrows on both tyre sidewalls
indicate the direction of rotation.
If a spare wheel has to be fitted
• Park your vehicle in such with the arrows pointing in the
a position that neither the opposite direction to the direction
traffic nor you are hindered or of rotation, have the tyre
endangered when changing a remounted in the correct
wheel. direction by an expert as soon as
possible.
• Set up a warning triangle.
• Ensure that the vehicle is on
firm, level ground. Spare wheel
• If necessary, secure the vehicle
with suitable chocks. Use only approved wheel
and tyre sizes. Using other
• Point the front wheels straight sizes could damage the vehicle
ahead. and will make the National Type
• Switch off the ignition and Approval invalid.
apply the handbrake.
• Select first or reverse gear. If the spare wheel differs
With Durashift EST, depress the from the other fitted
footbrake and select the gear wheels, these rules must be
before switching off the ignition. followed:
If the vehicle has an automatic
transmission, select the P • Do not exceed 80 km/h.
position.
• Drive the shortest possible
distances.
The vehicle jack must only • Do not fit more than one spare
be used to carry out wheel wheel on your vehicle at any one
changes. Do not work under the time.
vehicle when it is supported only
by the jack.
151
Roadside emergencies
• Do not use snow chains on this
type of wheel.
• Do not drive through an
automatic car wash.
• Vehicles with Electronic Stability
Program (ESP) may exhibit some
unusual driving characteristics.
Switch the ESP off. Refer to the
section Electronic Stability
Program (ESP), page 101
onwards. • Raise the rear of the floor cover in
the luggage compartment and
• If the spare wheel is used on the remove it.
rear axle of vehicles with Durashift
EST, the system may not be able to • Completely unscrew the retaining
select a higher gear in automated device anticlockwise.
mode (AUTO). This is due to the
different size of the spare wheel
and the standard wheel/tyre
combination. Select manual mode
to shift into a higher gear. After
replacing the spare wheel with the
standard wheel, normal operation in
automated mode (AUTO) will
return.
The vehicle may exhibit
some unusual driving
characteristics or engine
overheating may occur if you use
the spare wheel on the rear axle
• Remove the spare wheel cover.
in automated mode (AUTO) for
longer than a temporary period. • Lift out the spare wheel.
Select manual mode to shift • Install the defective wheel in the
gears. reverse order.
152
Roadside emergencies
Vehicle jack Jacking points
153
Roadside emergencies
Removing a wheel
• Make sure that the vehicle is on a
flat surface and the front wheels are
pointing straight ahead.
• Switch off the ignition and apply
the handbrake.
• Select reverse or 1st gear.
With Durashift EST, depress the
footbrake and select the gear before
switching off the ignition.
Points can be used for trolley
jacks, workshop hoists or jack If the vehicle has an automatic
stands. Points can be used for transmission select the P position.
trolley jacks in the centre, front or • Have the passengers leave the
rear. vehicle.
Positioning at other points may • If necessary, secure the vehicle
cause considerable damage to the against rolling or sliding by using
body, steering, suspension, engine, suitable wheel chocks.
braking system or fuel lines.
154
Roadside emergencies
Fitting a wheel
Alloy wheels must never be
secured using wheel nuts for
steel wheels.
155
Roadside emergencies
BATTERY
Maintenance
The battery requires very little
maintenance. The fluid level is
checked during the routine service
inspections.
Ignition warning light
156
Roadside emergencies
JUMP STARTING
Connect batteries with only the
same nominal voltage (12 volts).
Use jump leads with insulated
clamps and adequate size cable. Do
not disconnect the battery from the
vehicle’s electrical system.
To connect the leads
• Position the vehicles so that they
do not touch one another.
• Switch off the engine. Switch off
electrical equipment.
• Connect the positive (+) terminal
of the flat battery to the positive
(+) terminal of the booster battery
.
• Connect one end of the second
lead to the negative (–) terminal
of the booster battery .
• Do not connect to the
negative (–) terminal of the flat
battery.
• On vehicles with a petrol
engine, connect the other end of
lead as far away from the battery
as possible to the engine block or
the engine mount of the engine to
be started.
• On vehicles with a diesel
engine, connect the other end of
lead to the turbo charger of
the engine to be started (as shown
in the graphic). Flat battery
• Make sure that the jump leads are Booster battery
clear of moving parts of the engine.
157
Roadside emergencies
To start the engine TOWING THE VEHICLE
• Run the engine of the vehicle The screw-in towing eye is attached
with the booster battery at to the jack in the luggage
moderately high speed. compartment.
• Start the engine of the vehicle The towing eye must always be
with the flat battery. carried in the vehicle.
• Run both vehicles for a minimum
of three minutes before
disconnecting the leads.
Do not switch on the
headlights when
disconnecting the leads. The peak
voltage could blow the bulbs.
158
Roadside emergencies
159
Roadside emergencies
Towing vehicles with automatic Starting vehicles by towing or
transmission pushing
When a vehicle with an automatic To prevent damage you
transmission is towed, the selector must not push- or tow-start
lever must be in position N your vehicle. Use jump leads and
(neutral). a booster battery.
Never tow a vehicle with an
automatic transmission
faster than 50 km/h or further
than 50 kilometres.
160
Cleaning
WASHING YOUR VEHICLE Cleaning the headlights
The best procedure is brushless To avoid damaging the clear plastic
washing in a good car wash headlight lens do not use aggressive
installation. abrasives or chemical solvents. Do
not wipe the lights when they are
In installations operating dry or use sharp objects to clean
with high water pressure, the lenses.
water might be forced into the
vehicle’s interior or parts may get Cleaning the rear screen
damaged.
To avoid damaging the heating
elements when cleaning the inside
Unscrew and remove the of the rear screen use only a soft
radio aerial before entering cloth or a damp chamois leather. Do
an automatic car wash. Switch off not use solvent or sharp objects to
the heater blower to prevent clean the glass.
contamination of the fresh air
filter. Cleaning seat belts
Use Interior Cleaner or clean warm
water. Dry naturally, away from
If a waxing cycle is selected, please artificial heat.
ensure that the wax is removed
from the front screen afterwards. Do not use chemical cleaners,
boiling water, bleach, or dye. Do not
allow moisture to penetrate the seat
belt retractor mechanism.
161
Cleaning
PAINT CHIP REPAIR BODY PAINTWORK
Paint damage from road chippings PRESERVATION
or minor scratches can be repaired Wax the body paintwork of your
using aerosol paint spray or vehicle once or twice a year. This
touch-up paint. The Ford Accessory will help retain the glossy paintwork
range is recommended. Observe the finish and water droplets will run
application instruction on each off more easily.
product.
When polishing your vehicle
To retain vehicle warranty ensure that polish does not
on paintwork, remove come into contact with the plastic
apparently harmless looking but surfaces as it may prove difficult
often aggressive particles from to remove.
the paintwork immediately - e.g.
bird droppings, tree resins, insect Do not polish the vehicle in strong
remains, tar spots, road salt and sunshine.
industrial fall-out.
Do not apply polish to front or rear
screen, as this may result in poor or
noisy wiper action.
162
Maintenance
SERVICING Maintenance chart
• Check and top up fluid levels
regularly. Every day check:
• Check tyre pressure.
• Check brakes and lights are • Operation of all exterior and
operating correctly. interior lights and make sure
that all lenses are clean.
• Check warning and indicator
lights.
When refuelling check:
The electronic ignition
system works with high • Engine oil level
voltage. Never touch these
• Brake fluid level
components with the engine
running or the ignition switched • Screen washer fluid level
on.
• Tyre pressures and condition
(only when cold)
The ignition must be
switched off before working Once a month check:
in the engine compartment.
Under some operating conditions, • Coolant level (engine cold)
the cooling system fan may
continue to run for several • Assemblies, pipes, hoses and
minutes after the engine has been reservoirs for leaks
switched off. This is quite normal. • Power steering fluid level
Take care not to get any fingers or • Operation of air conditioning
clothing such as ties or scarves
caught in the fan. • Operation of handbrake
• Operation of horn
163
Maintenance
Opening the bonnet
164
Maintenance
Engine compartment
Position Description See page
Engine coolant reservoir1 169
Engine oil filler cap1 168
Auxiliary fuse box −2
Brake/clutch fluid reservoir1 168
Battery 156
Screen washer fluid reservoir
170
(Power steering fluid reservoir3)
No maintenance
Air cleaner
necessary
Engine oil dipstick1 167
Power steering fluid reservoir
170
(Screen washer fluid reservoir3)
1 For easy identification, filler caps and the engine oil dipstick are marked in colour.
2 The replacement of these fuses/relays requires specialised knowledge.
Please ask an expert to check them.
3 1.6 l Duratorq-TDCi engine only.
1.25/1.4/1.6 l Duratec
165
Maintenance
1.4 l Duratorq-TDCi
1.6 l Duratorq-TDCi
166
Maintenance
Engine oil dipstick
The oil consumption of new engines
reaches the normal value only after
approximately 5 000 km.
Make sure the vehicle is standing
on level ground. Check the engine
oil before starting the engine. If the
engine was running, switch it off
and wait some minutes for the
engine oil to flow back into the
sump before checking it. Pull out
the dipstick, wipe it with a clean,
non-fluffy cloth, re-insert it
completely and pull it out once
more.
If the level lies between the marks,
there is no need to refill. Hot oil
may exceed the MAX mark by some
millimetres due to thermal
expansion.
If it lies at the MIN mark refill using
only engine oil meeting the Ford
specification.
Top up to only the upper mark
(MAX).
1.25/1.4/1.6 l Duratec engine
For further details, refer to section
Engine oil, page 174 and table 1.4 l Duratorq-TDCi engine
Capacities, page 174. 1.6 l Duratorq-TDCi engine
167
Maintenance
Oil pressure warning light To close, turn the cap clockwise
until it is fully tightened.
Brake/clutch fluid reservoir
If the light stays on after starting or Do not allow this fluid to
illuminates during a journey, stop make contact with the skin
immediately, switch off the engine or eyes. If this should happen
and check the engine oil level. rinse the affected areas
Top up straight away if the level is immediately with plenty of water
low. and contact your doctor.
168
Maintenance
Cooling system reservoir Take great care when
adding coolant. Avoid
spillage on any part of the engine.
169
Maintenance
Checking power steering fluid Screen washer systems
level
170
Maintenance
Checking wiper blades TYRE INFORMATION
171
Capacities and specifications
IDENTIFICATION NUMBERS Engine number
The engine number is located on
the engine block (seen in the
direction of travel):
xxxx kg • All engines – near gearbox on
front left-hand side facing the
radiator.
FUEL
Use only high quality fuel without
any supplemental additives or other
engine treatments.
Vehicles with a petrol engine
Use unleaded petrol according to
specification EN 228 or equivalent
with minimum 95 octane. Leaded
fuel or fuel/additives containing
other metallic compounds (e.g.
manganese-based) may damage the
emission system.
Vehicles with a diesel engine
Vehicle identification plate Use diesel fuel according to
The vehicle identification plate is specification EN 590 or equivalent.
located on the lower section of the Do not mix it with any oil, petrol or
right-hand front door pillar. other liquids.
Diesel fuels which contain a mix of
Vehicle identification number
up to 5 % RME (bio diesel) are
The number is located in the engine acceptable.
compartment. It is additionally
Prolonged use of supplemental
stamped onto a tag on the left-hand
additives to prevent fuel waxing is
side of the instrument panel.
not recommended. Do not add
kerosene, paraffin or petrol to
diesel fuels.
172
Capacities and specifications
173
Capacities and specifications
ENGINE OIL
Engine oil change Engine oil top-up
Use Ford/Motorcraft Formula E If you are unable to find an oil that
SAE 5W-30 engine oil. meets this specification, you must
Alternative engine oils with the use an oil of the viscosity
viscosity SAE 5W-30 meeting the SAE 5W-30, SAE 5W-40 or
requirements of Ford Specification SAE 10W-40 according to ambient
WSS-M2C913-B may also be used. temperatures, meeting the
requirements of either
For petrol engines, engine oil ACEA A1/B1 or ACEA A3/B3
meeting the Ford specification specifications. Use of these oils may
WSS-M2C913-A may also be used. result in longer cranking periods,
reduced engine performance,
reduced fuel economy and
increased emission levels.
VEHICLE FLUIDS
Capacities (litres)
1.4 l 1.6 l
1.25 l 1.4 l 1.6 l
Engine Duratorq- Duratorq-
Duratec Duratec Duratec
TDCi TDCi
Engine oil
– with filter 3.751/3.802 3.751/3.802 4.102/4.253 3.80 3.85
– without filter 3.50 3.50 3.75 3.40 3.45
Power assisted steering MAX mark
Cooling system
5.0 5.5 6.0
including heating
Screen washer system 2.5
Fuel tank 45 43
1 With engine oil filter EFL 500
2 With engine oil filter EFL 10
3 With engine oil filter EFL 600
174
Capacities and specifications
VEHICLE WEIGHT
Vehicle weight (kg)
1.25 l Duratec
EC base kerb weight 1157
Maximum payload 448
Permissible gross weight 1605
Permissible roof rack weight 25
1.4 l Duratec
EC base kerb weight 1156
Maximum payload 449
Permissible gross weight 1605
Permissible roof rack weight 25
1.4 l Duratec Durashift EST transmission
EC base kerb weight 1162
Maximum payload 443
Permissible gross weight 1605
Permissible roof rack weight 25
1.6 l Duratec without ESP
EC base kerb weight 1159
Maximum payload 446
Permissible gross weight 1605
Permissible roof rack weight 25
1.6 l Duratec with ESP
EC base kerb weight 1159
Maximum payload 441
Permissible gross weight 1600
Permissible roof rack weight 50
1.6 l Duratec Automatic transmission
EC base kerb weight 1164
Maximum payload 466
Permissible gross weight 1630
Permissible roof rack weight 25
175
Capacities and specifications
Vehicle weight (kg)
1.4 l Duratorq-TDCi without ESP
EC base kerb weight 1157
Maximum payload 483
Permissible gross weight 1640
Permissible roof rack weight 25
1.4 l Duratorq-TDCi with ESP
EC base kerb weight 1157
Maximum payload 478
Permissible gross weight 1635
Permissible roof rack weight 50
1.4 l Duratorq-TDCi Durashift EST transmission
EC base kerb weight 1162
Maximum payload 478
Permissible gross weight 1640
Permissible roof rack weight 25
1.6 l Duratorq-TDCi without ESP
EC base kerb weight 1165
Maximum payload 510
Permissible gross weight 1675
Permissible roof rack weight 25
1.6 l Duratorq-TDCi with ESP
EC base kerb weight 1165
Maximum payload 505
Permissible gross weight 1670
Permissible roof rack weight 50
176
Capacities and specifications
TYRE DATA Note: If the spare wheel rim or tire
size differs from the other wheels
Tyre pressure fitted, see also section Spare
The pressure for your spare tyre wheel, page 151 onwards.
should be set to the highest value When using winter tyres, the tyre
given for your vehicle/tyre size pressures recommended by the tyre
combination. manufacturer should be adhered to.
177
Capacities and specifications
Snow chains
Use only the recommended small Vehicles with Electronic Stability
link snow chains on the driving Program (ESP) may exhibit some
wheels (front). unusual driving characteristics
Snow chains must only be fitted to which can be avoided by switching
14" x 5.5" J (47.5 offset) steel the system off. Refer to the section
wheels with 185/60 R 14 winter Electronic Stability Program
tyres. (ESP), page 101.
Do not exceed 50 km/h. Remove In order to avoid damaging
the chains immediately on full-diameter wheel covers, they
snow-free roads. should be removed before driving
with snow chains.
The ABS will continue to function
normally.
178
Capacities and specifications
DIMENSIONS
Dimensions mm
A = Maximum length 4013
B = Overall width (including exterior mirrors) 1950/19631
C = Overall height (EC kerb weight) 1512-1543
D = Wheelbase 2486
E = Track front 1477-1487
rear 1435-1445
1 Vehicles with electrically operated outside mirrors
179
Capacities and specifications
ATTACHMENT POINTS FOR The installation of towing
TOWING EQUIPMENT equipment should only be
performed by an expert.
Distances mm1
A = Bumper – end of towball 133
B = Attachment point – centre of towball 12
C = Wheel centre – centre of towball 869
D = Centre of towball – side member 493
E = Inner side of side member 986
F = Centre of towball – centre 1. attachment point 436
G = Centre of towball – centre 2. attachment point 721
1 All measurements refer to towing equipment officially released by Ford.
180
Capacities and specifications
RADIO FREQUENCY REMOTE CONTROL
If the type approval of your remote It is recommended that you use the
control is inspected, refer to the remote control only in the countries
table below. listed.
433,92 MHz
5WK4 725/8686/8071
BAKOM 97.0946.K.P.
MCW 129/95 23/1997
272/3-1998
542/98
Ref.No.: 3K43D/3R1B9/SPLS-RX9/98
1 Hereby, Siemens, declares that this remote control is in compliance with the essential requirements and
other relevant provisions of Directive 1999/5/EC.
181
Capacities and specifications
ENGINE IMMOBILISATION SYSTEM
If the type approval of your engine immobilisation system is inspected,
refer to the table below.
Type approval of the engine immobilisation system
Country Official test number
No label required
–1
3043 104475A
M.C.W. 129/95 /(11)
–1
No type approval necessary.
WT/122/98 II
ENG 3/2/RFS29
M.Ł. S.H. Nr. 003/2002
1 Data not available at the time of printing.
182
Capacities and specifications
LPREQ-0259-2002
171
B.61.TK.0.22.00.00/4940−2632
FCC ID:
NT8-15607-PAT3XCVR
183
Index
A A
ABS. See Brakes Automatic transmission . . . 107-114
Activity console. See Storage areas Cold mode . . . . . . . . . . . . . . . . . 112
Air conditioning. See Heating, Drive modes . . . . . . . . . . . 111-114
ventilation and air conditioning Emergency park
Airbag . . . . . . . . . . . . . . . . . . . 87-92 position release . . . . . . . . . . . . 111
Airbag deactivation . . . . . . . 91-92 Gear display . . . . . . . . . . . . . . . 107
Airbag deactivation light . . . 91-92 Kickdown . . . . . . . . . . . . . . . . . 112
Airbag warning light . . . . . . . . . 91 Moving off . . . . . . . . . . . . . . . . . 110
Curtain airbags . . . . . . . . . . . . . . 90 Overdrive . . . . . . . . . . . . . . . . . 109
Front airbags . . . . . . . . . . . . . . . 88 Parking . . . . . . . . . . . . . . . . . . . 108
Passenger airbag deactivation . 91 Release button . . . . . . . . . . . . . 107
Side airbags . . . . . . . . . . . . . . . . 89 Selector lever lock . . . . . 107, 111
Anti-lock braking system (ABS). Selector lever positions . . 107-109
See Brakes Starting the vehicle . . . . . . . . . 105
Anti-theft alarm system . . . . . . . . 76 Stopping . . . . . . . . . . . . . . . . . . 110
Switch off the alarm . . . . . . . . . 76 Towing . . . . . . . . . . . . . . . . . . . . 160
Ashtray, Front ashtray . . . . . . . . . 63 Transmission/Engine systems fault
warning light . . . . . . . . . . . 113-114
Audio remote control. See Audio
systems Warning signal, audible . . . . . . 108
Audio systems Auxiliary heater . . . . . . . . . . . . . . 45
Audio remote control . . . . . . . . 58
Radio display . . . . . . . . . . . . . . . 33
184
Index
B C
Battery . . . . . . . . . . . . . . . . . . . . . 156 Cooling system
Booster battery . . . . . . . . 157-158 Antifreeze . . . . . . . . . . . . . . . . . 169
Disconnected battery . . . . . . . 156 Coolant . . . . . . . . . . . . . . . . . . . 169
Ignition warning light . . . . . . . 156 Coolant capacity . . . . . . . . . . . 174
Maintenance . . . . . . . . . . . . . . . 156 Temperature gauge . . . . . . . . . . 19
Remote control,
battery replacing . . . . . . . . . . . . 72 D
Body paintwork preservation . . 162 Date . . . . . . . . . . . . . . . . . . . . . . . . . 9
Bonnet . . . . . . . . . . . . . . . . . . . . . 164 Digital clock . . . . . . . . . . . . . . . 9, 20
Brakes . . . . . . . . . . . . . . . . . . 98-100 Dimensions . . . . . . . . . . . . . 179-180
ABS warning light . . . . . . . . . . . 99 Driving,
Anti-lock braking system Driving with a roof load . . . . . . . 136
(ABS) . . . . . . . . . . . . . . . . . . . . . 99 Driving with a
Brake fluid reservoir . . . . . . . . 168 catalytic converter . . . . . . . . . . . 126
Brake system warning light 98-99 Durashift EST . . . . . . . . . . . 115-121
Disc brakes . . . . . . . . . . . . . . . . . 98 Downshift (Kickdown) . . . . . . 120
Dual circuit braking system . . . 98 Driving on inclines . . . . . . . . . . 121
Emergency Brake Assist . . . . . 100 Gear display . . . . . . . . . . . . . . . 116
Handbrake . . . . . . . . . . . . . . . . 100 Parking . . . . . . . . . . . . . . . . . . . 121
Hazards on heavy breaking . . . 100 Starting the engine . . . . . . . . . 105
Stopping . . . . . . . . . . . . . . . . . . 120
C
Towing . . . . . . . . . . . . . . . . . . . . 159
Capacities and Transmission/Engine systems fault
specifications . . . . . . . . . . . 172-183 warning light . . . . . . . . . . 121, 122
Central door locking. See Locking Warning signal, audible . . . . . . 120
system
Children
Child restraints . . . . . . . . . . . 93-97
Childproof safety locks . . . . . . . 66
Mass group categories . . . . . . . . 94
Placement of child seats . . . 94-96
Cigar lighter . . . . . . . . . . . . . . . . . 63
Clock, digital. See Digital clock
Clutch fluid,
Clutch fluid reservoir . . . . . . . . . 168
185
Index
E F
Electronic Stability Program Filling capacities . . . . . . . . . . . . 174
(ESP) . . . . . . . . . . . . . . . . . . 101-102 First aid kit . . . . . . . . . . . . . . . . . 138
Engine compartment . . . . . 165-166 Fog lights. See Lights
Engine oil . . . . . . . . . . . . . . 167-168 Front and rear screen, heated . . 45
Capacities . . . . . . . . . . . . . . . . . 174 Front screen, heated . . . . . . . . . . 45
Engine oil dipstick . . . . . . . . . . 167 Fuel . . . . . . . . . . . . . . . . . . . . . . . 172
Engine oil filler cap . . . . . . . . . 168 Diesel fuel . . . . . . . . . . . . . . . . . 172
Oil pressure warning light . . . . 168 Diesel low fuel safety mode . . 124
Oil specifications . . . . . . . . . . . 174 Filling up . . . . . . . . . . . . . . . . . . 125
Engine speed limiter . . . . . . . . . 103 Fuel consumption . . . . . . . . . . 173
Engines Fuel gauge . . . . . . . . . . . . . . . . . 19
Bonnet . . . . . . . . . . . . . . . . . . . . 164 Incorrect fuel . . . . . . . . . . . . . . 125
Compartment . . . . . . . . . . 165-166 Low fuel level warning light . . 124
Coolant . . . . . . . . . . . . . . . . . . . 169 Petrol fuel . . . . . . . . . . . . . . . . . 172
Diesel engine, starting . . . . . . . 104 Refuelling . . . . . . . . . . . . . . . . . 124
Diesel engine, switching off . . 104 Specifications . . . . . . . . . . . . . . 172
Diesel low fuel safety mode . . 124 Tank capacity . . . . . . . . . . . . . . 174
Disconnected battery . . . . . . . 156 Unleaded . . . . . . . . . . . . . . . . . . 172
Engine immobilisation Fuel filler flap . . . . . . . . . . . . . . . 125
system . . . . . . . . . . . . . . . . . . 73-75
Engine immobilisation Fuel injection system
system, type approval . . . 182-183 shut-off switch . . . . . . . . . . . . . 139
Engine number . . . . . . . . . . . . . 172
Fuses . . . . . . . . . . . . . . . . . . 140-143
Engine warning light . . . . . . . . 123
Limited operation strategy G
programme . . . . . . . . . . . . . . . . 138
Oil . . . . . . . . . . . . . . . 167-168, 174 Gauges . . . . . . . . . . . . . . . . . . . 19-21
Petrol engine, flooded . . . . . . . 103 Glove compartment. See Storage
areas
Petrol engine, starting . . . . . . . 103
Running in . . . . . . . . . . . . . . . . . 13
Environment protection . . . . . . . 13
186
Index
H I
Handbrake . . . . . . . . . . . . . . . . . . 100 Identification numbers . . . . . . . 172
Hazard flasher switch . . . . . . . . 138 Ignition switch . . . . . . . . . . . . . . 102
Hazards on heavy braking . . . . . . 33 Immobilisation system . . . . . . 73-75
See also Brakes Coded keys . . . . . . . . . . . . . . . . . 73
Head restraints. See Seats Indicator lights. See Warning and
Heating, ventilation and air indicator lights
conditioning . . . . . . . . . . . . . . 36-44 Information messages . . . . . . 26-29
Active carbon filter . . . . . . . . . . 36 Instrument cluster . . . . . . . . . 16-21
Adjusting the temperature . . . . 38 Instrument panel . . . . . . . . . . 14-15
Air conditioning . . . . . . . 37, 40-41 Interior lights. See Lights
Air conditioning,
maintenance . . . . . . . . . . . . . . . 163 J
Air distribution . . . . . . . . . . . 38, 43 Jack . . . . . . . . . . . . . . . . . . . . . . . 153
Blower . . . . . . . . . . . . . . . . . . . . . 38 Jacking points . . . . . . . . . . . 153-154
Controls . . . . . . . . . . . . . . . . . . . . 38 Jump starting . . . . . . . . . . . 157-158
Defrosting the windows . . . 39, 43
Electronic automatic K
temperature control . . . . . . 41-43
Keys. See Locking system
Fresh air filter . . . . . . . . . . . . . . 36
General notes . . . . . . . . . . . . . . . 37
Rapid cooling . . . . . . . . . . . . . . . 40
Recirculated air . . . . . . . . . . 36, 40
Vents . . . . . . . . . . . . . . . . . . . . . . 36
Horn . . . . . . . . . . . . . . . . . . . . . . . . 54
187
Index
L L
Lights Locking system
Autolamps . . . . . . . . . . . . . . . 46-47 Central door locking . . . . . . 68-72
Bulb replacement . . . . . . . 144-150 Childproof safety locks . . . . . . . 66
Dipped beam . . . . . . . . . . . . 46, 52 Doors open warning light. See
Direction indicator lever . . . . . . 51 Warning and indicator lights
Direction indicator light . . . . . . 52 Double locking . . . . . . . . . . . 68-71
Exterior lights, audible warning Ignition switch . . . . . . . . . . . . . 102
signal . . . . . . . . . . . . . . . . . . . . . . 46 Keys . . . . . . . . . . . . . . . . . . . . 64-65
Front fog lights . . . . . . . . . . . 47-48 Keys, coded for immobilisation
Hazards on heavy braking . . 33, 51 system . . . . . . . . . . . . . . . . . . . . . 73
Headlight flasher . . . . . . . . . . . . 52 Locking the vehicle . . . . . . . 70-71
Headlight levelling control . . . . 50 Locks . . . . . . . . . . . . . . . . . . . 65-67
Headlights . . . . . . . . . . . . . . . . . . 46 Luggage compartment . . . . 66-67
Home safe lights . . . . . . . . . . 48-49 Opening the bonnet . . . . . . . . . 164
Interior lights . . . . . . . . . . . . . . . 53 Remote control . . . . . . . . . . . 64-65
Lane change indicators . . . . 33, 51 Remote control,
Light switch . . . . . . . . . . . . . . . . 46 battery replacing . . . . . . . . . . . . 72
Main beam . . . . . . . . . . . . . . . . . 52 Remote control,
programming . . . . . . . . . . . . 71-72
Main beam indicator light . . . . . 52
Remote control,
Multifunction lever . . . . . . . . . . 51 type approval . . . . . . . . . . . . . . 181
Reading lights . . . . . . . . . . . . . . . 53 Reprogramming the unlocking
Rear fog light . . . . . . . . . . . . . . . 48 function . . . . . . . . . . . . . . . . . . . . 33
Side lights . . . . . . . . . . . . . . . . . . 46 Steering lock . . . . . . . . . . . . . . . 102
Welcome lights . . . . . . . . . . . . . . 49 Unlocking the vehicle . . . . . . . . 69
Luggage compartment
Closing the tailgate . . . . . . . . . . 67
Increasing load floor . . . . . . 81-82
Luggage cover . . . . . . . . . . . . . 127
Luggage net . . . . . . . . . . . . . . . 128
Opening the tailgate . . . 66-67, 69
Transporting luggage . . . . 126-127
Warning light, luggage
compartment . . . . . . . . . . . . . . . 67
188
Index
M M
Maintenance chart . . . . . . . . . . . 163 Multifunction display . . . . . . . 20-21
Manual transmission . . . . . . . . . 106 Multifunction lever. See Lights
Map pockets. See Storage areas
O
Message Centre . . . . . 20-21, 22-35
Average fuel consumption . . . . 25 Odometer . . . . . . . . . . . . . . . . 21, 25
Average speed . . . . . . . . . . . . . . 25 Oil types . . . . . . . . . . . . . . . . . . . 174
Chime deactivation . . . . . . . . . . 34
P
Controls . . . . . . . . . . . . . . . . . . . . 22
Display warning light . . . . . . 26-29 Paint chip repair . . . . . . . . . . . . . 162
Distance to empty . . . . . . . . . . . 25 Parking . . . . . . . . . . . . . . . . . . . . 126
Fuel economy . . . . . . . . . . . . . . . 25 Automatic transmission . . . . . 108
Main menu overview . . . . . . . . . 24 Durashift EST . . . . . . . . . . . . . . 121
Measure units . . . . . . . . . . . . . . . 35 Handbrake . . . . . . . . . . . . . . . . 100
Odometer . . . . . . . . . . . . . . . . . . 25 Parking on a hill . . . . . . . . . . . . 100
Outside temperature . . . . . . . . . 25 Ultrasonic park distance
Setting the language . . . . . . 34-35 sensor . . . . . . . . . . . . . . . . . . . . 137
Settings menu . . . . . . . . . . . 31-35 Power point . . . . . . . . . . . . . . . . . . 63
Settings menu overview . . . . . . 32 Power windows. See Power
windows
Time setting . . . . . . . . . . . . . . . . 30
Tripmeter . . . . . . . . . . . . . . . . . . 25 Preface . . . . . . . . . . . . . . . . . . . . . 12
Warning/information R
messages . . . . . . . . . . . . . . . . 26-29
Mirrors Radio frequency remote control,
type approval . . . . . . . . . . . . . . . 181
Interior rear-view mirror . . . . . . 59
Rear screen, heated . . . . . . . . . . . 45
Outside rear-view mirrors,
electrically operated . . . . . . . . . 60 Refill capacities . . . . . . . . . . . . . 174
Outside rear-view mirrors, Reverse gear wipe. See Screen
convex . . . . . . . . . . . . . . . . . . . . . 59 washing/wiping
Outside rear-view mirrors, Roof rack . . . . . . . . . . . . . . . . . . . 136
folding . . . . . . . . . . . . . . . . . . 59, 60
Outside rear-view mirrors,
heated . . . . . . . . . . . . . . . . . . . . . 60
Outside rear-view mirrors,
manually . . . . . . . . . . . . . . . . . . . 59
189
Index
S S
Screen washing/wiping Servicing . . . . . . . . . . . . . . . 163-171
Autowipers . . . . . . . . . . . . . . 55-56 Socket/cigar lighter . . . . . . . . . . . 63
Front screen wiping . . . . . . . 55-56 Speedometer . . . . . . . . . . . . . . . . . 19
Intermittent wipe interval . . . . . 55 Starting the engine . . . . . . 103-104
Rear screen washing/wiping . . . 57 Starting, general points . . . . . . . 103
Reverse gear wipe . . . . . . . . . . . 57 Steering
Washer . . . . . . . . . . . . . . . . . . . . . 57 Adjusting the steering wheel . . 54
Washer fluid capacity . . . . . . . 174 Power steering fluid level . . . . 170
Washer fluid reservoir . . . . . . . 170 Steering lock . . . . . . . . . . . . . . . 102
Washer jets . . . . . . . . . . . . . . . . 170
Storage areas
Wiper blades . . . . . . . . . . . . . . . 171
Activity console . . . . . . . . 131-132
Wiper lever . . . . . . . . . . . . . . 55-57
Card holder . . . . . . . . . . . . . . 2, 129
Seat belts . . . . . . . . . . . . . . . . . 82-86 Coin holder . . . . . . . . . 2, 129, 130
Adjusting the height . . . . . . . . . 83 Front storage
Care of seat belts . . . . . . . . . . . . 86 compartment . . . . . . . . . . . . 2, 128
Pregnant women . . . . . . . . . . . . 84 Glove compartment . . . . . . . 2, 129
Seat belt pretensioner . . . . . . . . 85 Map pockets . . . . . . . . . . . . . 4, 130
Seat belt pretensioner warning Pencil clip . . . . . . . . . . . . . . . 2, 129
light . . . . . . . . . . . . . . . . . . . . . . . 91 Storage area passenger side . . 128
Seats . . . . . . . . . . . . . . . . . . . . 77-82 Storage compartment . . . . . 2, 128
Armrest . . . . . . . . . . . . . . . . . . . . 78 Storage pockets . . . . . . . . . . 3, 130
Child restraints . . . . . . . . . . . 93-97 Under-seat storage . . . . . . . . 3, 129
Correct position . . . . . . . . . . . . . 77 Storage pockets. See Storage areas
Fold flat front passenger seat . . 79
Sun visors . . . . . . . . . . . . . . . . . . . 62
Folding the rear
seatback forwards . . . . . . . . . . . 81 Sunroof . . . . . . . . . . . . . . . . . . . . . 62
Folding the seat cushion and
seatback forwards . . . . . . . . . 4, 82
Head restraints . . . . . . . . . . . . . . 80
Heated front seats . . . . . . . . 79-80
Mass group categories . . . . . . . . 94
Seat covers . . . . . . . . . . . . . . 77, 90
190
Index
T U
Tachometer . . . . . . . . . . . . . . . . . . 19 Under-seat storage. See Storage
Towing areas
Attachment points . . . . . . . . . . 180 V
Pushing/towing . . . . . . . . . 158-160
Starting by towing or pushing 160 Vehicle care . . . . . . . . . . . . . . . . 161
Towing eye . . . . . . . . 153, 158-159 Vehicle fluids . . . . . . . . . . . . . . . 174
Trailer Capacities . . . . . . . . . . . . . . . . . 174
Tow bar . . . . . . . . . . . . . . . 133-136 Specification . . . . . . . . . . . . . . . 174
Trailer coupling, Vehicle identification number . . 172
removable . . . . . . . . . . . . . 133-136 Vehicle identification plate . . . . 172
Trailer towing . . . . . . . . . . . . . . . 133 Vehicle weight . . . . . . . . . . 175-176
Steep gradients . . . . . . . . . . . . 133 Ventilation. See Heating, ventilation
Tripmeter . . . . . . . . . . . . . . . . 21, 25 and air conditioning
Tyres and wheels
Changing a wheel . . . . . . . 151-156
Directional tyres . . . . . . . . . . . 151
Fitting a wheel . . . . . . . . . 155-156
Jacking up . . . . . . . . . . . . . 153-155
Removing a wheel . . . . . . 154-155
Snow chains . . . . . . . . . . . . . . . 178
Spare wheel . . . . . . . . . . . 151-152
Tyre data . . . . . . . . . . . . . . 177-178
Tyre information . . . . . . . . . . . 171
Tyre pressure . . . . . . . . . . 177-178
191
Index
W W
Warning and indicator lights Warning lights. See Warning and
ABS warning light . . . . . . . . . . . 99 indicator lights
Airbag deactivation light . . . 91-92 Warning messages . . . . . . . . . 26-29
Airbag/seat belt pretensioner Warning signal, audible
warning light . . . . . . . . . . . . . . . . 91 Automatic transmission . . . . . 108
Brake system Chime deactivation . . . . . . . . . . 34
warning light . . . . . . . . 98, 99, 168 Durashift EST . . . . . . . . . . . . . . 120
Direction indicator light . . . . . . 52 Exterior lights . . . . . . . . . . . . . . 46
Doors open warning light . . . . . 67 Low fuel level . . . . . . . . . . . . . . 124
Electronic Stability Program Message Centre, confirmation
(ESP) indicator light . . . . 101-102 chime . . . . . . . . . . . . . . . . . . . . . . 22
Engine warning light . . . . . . . . 123 Ultrasonic park
Front fog light distance sensor . . . . . . . . . . . . 137
indicator light . . . . . . . . . . . . 47-48 Warning symbols . . . . . . . . . . . . . 13
Frost warning . . . . . . . . . . . . . . 124
Warning triangle . . . . . . . . . . . . . 138
Glow plug indicator light . . . . . 104
Warranty . . . . . . . . . . . . . . . . . . . 162
Ignition warning light . . . . . . . 156
Washing the vehicle . . . . . . . . . . 161
Low fuel level warning light . . 124
Main beam indicator light . . . . . 52 Weights . . . . . . . . . . . . . . . . 175-176
Oil pressure warning light . . . . 168 Wheels. See Tyres and wheels
Overdrive indicator light . . . . . 109 Wiper lever. See Screen
Power steering . . . . . . . . . . . . . 123 washing/wiping
Rear fog light indicator light . . . 48
Transmission/Engine systems fault
warning light . . . 113-114, 121, 122
192