Professional Documents
Culture Documents
• Wide AC/DC power operating range from 100..260VAC / 8..36 VDC. Antennas.
• On-board high-capacity Li-Ion battery. Cable parts.
• 12/24 Volt DC-out capability for powering external equipment. 1-Wire
• Advanced power-management with wake-up on a wide range of events.
parts.
• High-speed mini-USB programming connector.
• Intrusion detection. Industrial SD-CARD.
• Housed in an ruggedized plastic encapsulation with cable glands. ...and more.
• IP65 protected for outdoor usage.
• Fully supported by the RTCU Gateway 2 and the RTCU Deployment Server.
• Accessories: Bluetooth, Camera, 1-wire accessories, MODBUS modules, etc.
To learn more about the technical details and usage of the RTCU AX9 turbo, please download the
”RTCU AX9 turbo Technical Manual”.
Also make sure to get the FREE RTCU IDE Development Environment, RTCU Gateway 2 and the Deployment Server to
get a hands-on experience how rapid development/deployment of game changing M2M/IoT applications were meant to be.
• 8 MB internal FAT32 flash drive. • Digital input #5 can be used as ignition. • Standard RJ45 Ethernet connector.
• 1 MB circular automatic datalogger. • 4 x analog inputs.
• 20 KB FRAM with fast access /
Range is 0..10VDC or 0..20 mA External Interfaces.
Resolution: 12 bit
unlimited write endurance. • SMA Female connector for external
Precision: ±1.5% FSR @ 25°C
• SD-CARD reader with up to 32 GB. GSM antenna.
• 4 x analog outputs.
• 3 x PG11 cable glands.
Range is 0..10VDC or 0..20 mA
GSM Resolution: 10 bit • 2 x PG9 blind plugs.
• Qualcom QSC6270 single chip. Precision: ±1.5% FSR @ 25°C
• 3G / HSDPA with up to 3.6 Mbps. • Protected against transients and low- Physical Characteristics
pass filtered. • Encapsulation:
• UMTS / EDGE / GPRS support.
• Expandable I/O with MODBUS. Durable Polycarbonate plastic.
• CSD with up to 64 Kbps.
• Approx. 690 gram without accessories.
• SMS / PDU.
Communication • W 130 x H 180 x D 60 mm.
• DTMF decoding / transmission. (wihout SMA and PG connectors.
• 10BASE-T Ethernet inferface.
• Digitized voice playback / IVR.
• 1 x RS232 with control signals.
• eCall Accident / Emergency services. Environmental Specification
• 1 x RS485.
• Mini-SIM 1.8/3 volt. • Operating temperature: -30 to 60°C.
• 1 x shared RS232 / RS485.
• Internal SIM card-reader. • Battery charge temperature:
• 1-Wire bus.
• Internal GSM antenna. -10 to 45 °C
• On-board 868 Mhz ISM RF
• External or internal antenna selecable Up to 15 meter indoor / • Recommended storage temperature:
by DIP-switch or user application. Up to 50 meter outdoor. 0 to 45°C.
• Optional Gemalto eSIM. • ISM RF can be disabled for world-wíde • Humidity: 5..90% (non condensing).
compliance requirements. • Ingress Protection: IP65.
User Interaction
• Three bi-colour LED / Yellow status. Power Management Approvals
• DIP-switches. • 5 execution speeds. • R&TTE 1995/5/EC.
• Reset/recovery switch. • Wait for Event: Timer, Digital input, • CE. EMC directive 2004/108/EU.
• Antenna selection dip-switch. RS232, GSM, Power change state, RF • GSM engine: CE/GCF/FCC/PTCRB.
• Configuration jumpers. and Intrusion.
• Mini-USB for service port. • Wait for event, from: 600 uA@12V.
Warranty
• Intrusion-detection. • Supervision of supply voltage / type.
• Two-years return to factory parts and
labor.
Battery and Charger Electrical Specification. • Optional warranty up to 5 years.
• On-board 2Ah (nominal) Li-Ion battery. • Supply operating range: (restrictions apply).
• Intelligent charger with temperature 8 to 36 VDC.
throttle and sub-zero degrees support. 100 to 260 VAC.
• On-board temperature sensor. • Short and reverse power protected. Note: Some features are currently under development.