Professional Documents
Culture Documents
SAFETY NOTE:
NEVER PLACE dry ice into a closed container such as a soda bottle. The bottle can
explode with a loud bang, damaging your eardrums. Loose plastic, such as the bottle
cap, may fly off, damaging someone's eyes. THIS HAS
HAPPENED! (VIDEO) DON'T DO IT!
At normal atmospheric pressure on this planet, frozen CO2 doesn't melt into a liquid,
but rather evaporates directly into its gaseous form. Hence the name dry ice. This
process is called sublimation. All of the experiments below rely on this property of dry
ice. 1 pound of dry ice, when it sublimates (turns to gas) will produce 250 liters of gas
at atmospheric pressure, enough to fill 125 2-liter bottles. That's a lot of gas!
Inflate A Balloon
Grab an uninflated balloon and force the neck open with the index and middle fingers
of both hands, stretching the balloon open. This will allow a partner to drop in one or
more pellets of dry ice. Tie the balloon closed. Set aside, and observe for awhile. Better
yet, drop the balloon into a pond or swimming pool. This will help supply heat to the
dry ice. At first, the balloon will sink, but soon, as it begins to inflate, it will rise to the
surface.
If you manage to put enough dry ice into the balloon, it will eventually reach the
bursting point. Again, this is lots of fun if the balloon is in a pool.
Hero's Engine
Using a push pin, or a straight pin held in pliers, poke two holes into
opposite sides of a film can, near the bottom. The holes should be off -
center, like pinwheel rockets. Tie a loop in a length of thread. The
loop should fit loosely over the cap of the film can, so that when you
loop it over the cap, and snap the cap onto the can, you can hold the
can by the remaining length of thread. Place a small piece of dry ice
into the can. Then quickly add some warm water, and close the lid,
with the thread attached. Lift the can by the thread, and watch what
happens.
Singing Spoon
Hold a warm spoon by its handle, and press itfirmly against a chunk of dry ice. The
spoon will scream loudly as the heat of the spoon causes the dry ice to instantly turn to
gas where the two make contact. The pressure of this gas pushes the spoon away from
the dry ice, and without contact, the dry ice stops sublimating. The spoon falls back
into contact again, and the cycle repeats. This all happens so quickly that the spoon
vibrates, causing the singing sound you hear.
Fog Effects
When you place dry ice into some warm or hot water, clouds of white fog are created.
This white fog is not the CO2 gas, but rather it is condensed water vapor, mixed in with
the invisible CO2. The extreme cold causes the water vapor to condense into clouds.
The fog is heavy, being carried by the CO2, and will settle to the bottom of a container,
and can be poured. You can produce enough ground - hugging fog to fill a medium
sized room with a pound or so of dry ice. Do not allow anyone to lay down in this fog,
or allow babies or pets into it, as CO2 gas does not support life. Dry ice fog allows low
powered laser beams to be seen; see the laser experiments page for details.
Also, see our Fog Generator page.
Carbonation
Dry ice, being frozen CO2 gas, can be used to carbonate water to create sparkling
water. Place some drinking water in a glass, and add some dry ice. Allow it to bubble.
Water ice may form around the dry ice. If this happens you can either leave it alone, or
break it up with a spoon to help the process along. When all of the dry ice is gone, taste
the water that remains. It should taste slightly carbonated.
I haven't tried to see what happens when you do this in a closed container, as I haven't
yet determined what is a safe quantity of dry ice to add, that will carbonate the water
yet not burst the container. See safety note above. So I would strongly caution you
against doing this, unless you take the proper safety precautions, such as providing a
secondary container (a coffee can perhaps?) to catch any projected pieces of plastic
soda bottle. Also, cover your ears or use earplugs, just in case the container
bursts. Don't do the experiment in a glass container! If you do this experiment, take
careful data, and email me the results. I'd be interested in what you find out!
MORE INFO
See our Dry Ice Experiment Feedback page!
You can also visit dryiceINFO.com for more info about the physical properties of dry
ice, where to buy it, how to ship food with it, Halloween uses, and all sorts of things.
See this CARBONATION page for information about building a home-carbonation
unit.
These two websites are outside my website. They are an excellent resource for anyone
interested in dry ice and carbonation!
View our all-time most popular science projects
You might also like these projects