You are on page 1of 5

PPC Beam Data Spreadsheet Version 1.

Project No. Notes: Beam Bearing Assembly Height


Design No. Bridge Designer to fill in gray ce
County * Bridge Contractor to document
Other Info. ** Central Construction and Mater
*** Bridge Contractor to document

Beam Design Camber ** Actual Camber


Size * Beam Initial Final Initial
Beam (e.g. BTB120) Number (BN) (in) (in) (in)
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
Last Revised on 11-23-2015

eam Bearing Assembly Height is the total height of the bearing assembly excluding any components embedded in the beam.
ridge Designer to fill in gray cells and set up spreadsheet to match plan set.
ridge Contractor to document individual beam identification number as installed on the bridge.
entral Construction and Materials to document the initial and final actual beam cambers for each beam installed.
ridge Contractor to document as constructed (actual) beam seat elevation at each substructure unit for each beam line.

BEAM INFORMATION

** Actual Camber Beam Bearing Height Plan


Final ? Abut. Pier #1 Pier #2 ? Abut. ? Abut. Pier #1
(in) (in) (in) (in) (in)
ded in the beam.

h beam line.

Beam Seat Elevation


Plan *** Actual
Pier #2 ? Abut. ? Abut. Pier #1 Pier #2 ? Abut.
Note: Bridge Designer shall adjust figure below as necessary to match the let bridge plans.
Drawing not to scale.

C.L. ? ABUT. BRG. C.L. PIER #1


1 8
Beam Line A

2 9
Beam Line B

3 10
Beam Line C

4 11
Beam Line D

5 12
Beam Line E

6 13
Beam Line F

7 14
Beam Line G
h the let bridge plans.

C.L. PIER #2 C.L. ? ABUT. BRG.


15

16

17

18

19

20

21

You might also like