Professional Documents
Culture Documents
Schematic:
Assumptions: (1) Sphere walls are isothermal, (2) Test surface area
is small compared to the enclosure surface.
G 1 E b (Ts ) Ts4
(2) Note that the test surface area must be small compared to the
enclosure surface area. This allows for inter-reflections to occur
such that the radiation field, within the enclosure will be uniform
(diffuse) or isotropic.
(3) The irradiation level would be the same if the enclosure were not
evacuated since; in general, air would be a non-participating
medium.
2 Assuming the earth’s surface is black, estimate its temperature
if the sun has an equivalently blackbody temperature of
5800K.The diameters of the sun and earth are 1.39*109 and
1.29*107m, respetively, and the distance between the sun and
earth is 1.5*1011m.
Schematic:
Ae , p .G S Ae , s . E b (Te )
Te G S / 4
1/ 4
Where As,p and Ae,s are the projected area and total surface
area of the earth, respectively. To determine the irradiation
GS at the earth’s surface, perform an energy bounded by the
spherical surface shown in sketch
. .
E in E out 0
D S2 .TS4 4 [ RS ,e De / 2]2 G S
G S 1377 .5W / m 2
Comments:
(2) Note carefully the different areas used in the earth energy
balance. Emission occurs from the total spherical area, while
solar irradiation is absorbed by the projected spherical area.
3 The spectral, directional emissivity of a diffuse material at
2000K has the following distribution.
Schematic:
1.5 1.5
(T ) 1 ) E ,b ( ,2000)d / E b ) 2 E ,b ( ,2000)d / E b
0 0
1.5 2.5
0 0 E b (T ) E b (T )
2 sin2 / 6 T 4
E
1[F(01.5) F(00.8) ] 2 [F(02.5) F(01.5) ]}
0 2 0
Schematic:
"
q net G J 1000W / m 2 1249W / m 2 249W / m 2
Schematic:
Assumptions:
q I e As cos w a a
E b (T f ) T f4 5.67 10 8 (1500) 4
Ie 9.14 10 4 W / m 2 .sr
hence
q ( I e Aa cos 1 w a a )
where is the transmissivity of the window to radiation emitted by the furnace wall.
G d E .b (T f )d 2
0
0
0.8 ( E ,b / E b )d 0.8F( 0 2 m )
G d E d 0
,b
0 0
Schematic:
J=5000W/m2
T q”conv G
h= W/m2.K
Plate,T=350K,
h
G J
q”conv
2G 2q conv
"
2J
J E G G E (1 )G
J (1 )G ( 5000 W / m 2 ) 0 .6 ( 7000 W / m 2 )
0 .94
T 4
5 .67 10 8
W / m 2 .K 4
( 350 K ) 4
Hence
2G 2q conv
"
2E
hence
T 4 G h(T T )
0.4(7000W / m 2 ) 40W / m 2 . K (50 K )
0.94
5.67 10 8 W / m 2 . K 4( 350 K ) 4
7 An opaque, gray surface at 27C is exposed to irradiation of
1000W/m2, and 800W/m2 is reflected. Air at 17C flows over
the surface and the heat transfer convection coefficient is
15W/m2.K.Determine the net heat flux from the surface.
Schematic:
"
q net q conv
"
E G ref G h(Ts T ) Ts4 G ref G
1 1 (G ref / G ) 1 (800 / 1000) 1 0.8 0.2
where G ref /G. the net heat flux from the surface
"
q net (150 91.9 800 1000)W / m 2 42W / m 2
Note the need to assume the surface is diffuse, gray and opaque
in order that Eq (2) is applicable.
8. A small disk 5 mm in diameter is positioned at the center of an
isothermal, hemispherical enclosure. The disk is diffuse and gray
with an emissivity of 0.7 and is maintained at 900 K. The
hemispherical enclosure, maintained at 300 K, has a radius of
100 mm and an emissivity of 0.85.
Schematic:
qap
R=100mm perture( z D mm
Ts=300K,
Disk(A1),T1=900K,Di=5mm,
q ap q1 2 G 2 .A2
1
q 1 2 J 1 . A1 cos 1 .w 21
Where the irradiatin G 1 is the emissive power of the black enclosure, E b (T3 );
21 A2 / R 2
Combining equations. (2), (3) and (4) into eq.(1) with G2=T43,
the radiant power is
1 A2
q ap [ 1T14 (1 1 )T34 ] A1 cos 1 . A2T34
R2
1
q ap 5.67 10 8 W / m 2 . K 4 [0.7(900 K ) 4 (1 0.7)( 300 K ) 4 (0.005m ) 2 cos 45
4
/ 4(0.002m ) 2
2
(0.002m )25.67 10 8 W / m 2 . K 4 ( 300 K ) 4
(0.100m ) 4