Professional Documents
Culture Documents
WARNING
Indicates a hazardous situation which, if not avoided, could result in death
or serious injury.
CAUTION
Indicates a hazardous situation which, if not avoided, could result in minor
or moderate injury and property damage.
On the lift truck, the WARNING symbol and word are on orange back-
ground. The CAUTION symbol and word are on yellow background.
Capacities and Specifications Table of Contents
TABLE OF CONTENTS
(MP20) [A249];
(MPB045VG) [A245]
Hydraulic System
Operating Ampere Lower Time
Relief Setting Lift Time (sec)
Pressure1 Draw2 (sec)
Unit Volts
No Rated No Rated Amp No Rated No Rated
Pressure3
Load Load Load Load Draw Load Load Load Load
MP20, MPB045VG 24 2.07 14.82 MPa 37 100 24.1 MPa 150 2.3 3.1 2.8 1.4
MPa (2150 psi) (3500 psi
(300 )
psi)
Standard Specifications Hydraulic Tank Capacity - 1.0 liter (1.06 qt) Pump Displacement (24 Volts) -
1.25 cm3/rev (0.076 in.3/rev) Creep Rate - 6.4 mm (0.25 in.) Maximum In 10 Minutes @ 32°C (90°F) Oil
Temperature
Footnotes 1 ±0.35 MPa (±51 psi) @ 21°C (70°F) Oil Temperature 2 ±10 Amps @ 1.270 Battery Specific Gravity
3
+0.6 to 0.0 MPa (+87 to 0 psi) @ 32°C (90°F) Oil Temperature Full Flow
Hydraulic Oils
Operating Condition Standard CS/Freezer
Truck Temperature Range 0 to −84°C (32 to −120°F) −18 to −84°C (0 to −120°F)
For All Hydraulically Actuated Equipment
Specification ISO VG 46 Antiwear (HCE-140) Exxon Univis® HVI 26
Pour Point Maximum −15°C (5.0°F) −60°C (−76.0°F)
Field Personnel Note: The product listed above is the approved source that meets or exceeds Yale specifications. The use
of products other than that listed above is unauthorized.
Grease
Fittings and Bearings
Application Standard/CS/Freezer Steer Bearings
Approved Vendor Mobilgrease 28®
Amsoil GHD®
Oil Synthetic Synthetic
Thickener Clay Lithium Complex
Grade NGLI 1.5 2.0
Moly-Fortified No Yes
Dropping Pt. 310°C (590°F) 288°C (550°F)
Field Personnel Note: The product listed above is the approved source that meets or exceeds Yale specifications. The use
of products other than that listed above is unauthorized.
1
Tires 8000 YRM 1511
Truck Weights
Fork Length Fork Length Fork Length
Unit
900 mm (35.4 in.) Weight 1000 mm (39.4 in.) Weight 1150 mm (45.2 in.) Weight
MP20, MP035-D and
518 kg (1142 lb) 523 kg (1153 lb) 530 kg (1168 lb)
MP045VG
Tires
Unit Size Item Torque
MP20 230 mm × 84 mm Wheel Lug Nut 120 N•m (88 lbf ft)
MPB045VG 254mm x 102mm Wheel Lug Nut 120 N•m (88 lbf ft)
Torque Specifications
CASTER ASSEMBLY Steering Bearing to MDU Casting (8)
23 N•m (17 lbf ft)
Caster Mounting Capscrews (4 each)
57 N•m (42 lbf ft) Drive Unit to Steering Bearing (8)
23 N•m (17 lbf ft)
Caster Axle Capscrews (2 each)
35 N•m (25 lbf ft) STEERING
Caster Pivot Bolt (1 each) Steer Bracket to MDU (4)
85 N•m (63 lbf ft) 19.2 N•m (15 lbf ft)
Transmission to Frame Mounting Bolts (4) Traction Motor Power Wire Nuts (3)
225 N•m (165 lbf ft) 8 N•m (71 lbf in)
Drive Tire Wheel Lug Nuts (5) Contactor to Control Panel (2)
120 N•m (88 lbf ft) 4 N•m (35 lbf in)
2
8000 YRM 1511 Torque Specifications
Contactor Wire Nuts (2) Rear Fork Pivot Shaft to Fork (2)
8 N•m (71 lbf in) 35 N•m (26 lbf ft)
Controller to Control Panel Nuts (4) Hydraulic Cylinder Gland Nut (1)
14 N•m (124 lbf in) 275 N•m (203 lbf ft)
3
Battery Specifications 8000 YRM 1511
Battery Specifications
Battery Compartment is shown in Figure 1.
Ampere Kilowatt
Compartment Compartment Recommended
Voltage Hours Hours Weight (Max)
Length (X) Width (Y) (Max) Height (Max)
(Max) (Max)
704 mm 223 mm 627 mm (24.7 in.) 212 kg
24 220 5.28
(27.7 in.) (8.78 in.) (467 lb)
Ampere Kilowatt
Compartment Compartment Recommended
Voltage Hours Hours Weight (Max)
Length (X) Width (Y) (Max) Height (Max)
(Max) (Max)
704 mm 153 mm (6.02 in.) 655 mm OPEN
24 110 4.58
(27.7 in.) (25.8 in.)
4
Thank you very much
for your reading.
Please Click Here
Then Get More
Information.