Professional Documents
Culture Documents
WCE0054
6. Keep the engine speed of the booster ve-
hicle at about 2,000 rpm, and start the en-
2. Apply the parking brake. Move the shift lever gine of the vehicle being jump started.
WARNING
to N (Neutral) (manual transmission) or to P
Always follow the instructions below. (Park) (automatic transmission). Switch off
Failure to do so could result in damage to
CAUTION
all unnecessary electrical systems (lights,
the charging system and cause personal heater, air conditioner, etc.). Do not keep the starter motor engaged for
injury. more than 10 seconds. If the engine does
3. Remove vent caps on the battery (if so not start right away, turn the key off and
1. If the booster battery is in another vehicle, equipped). Cover the battery with an old wait 3 to 4 seconds before trying again.
position the two vehicles to bring their bat- cloth to reduce explosion hazard.
teries near each other. 7. After starting the engine, carefully discon-
4. Connect jumper cables in the sequence il- nect the negative cable and then the positive
Do not allow the two vehicles to touch. lustrated (s
A,s
B,s C,sD ). cable.
3. Get out of the vehicle. Look and listen for 6. After the engine cools down, check the cool- When towing your vehicle, all State (Provincial in
steam or coolant escaping from the radiator ant level in the engine coolant reservoir tank Canada) and local regulations for towing must be
before opening the hood. (If steam or cool- with the engine running. Add coolant to the followed. Incorrect towing equipment could dam-
ant is escaping, turn off the engine.) Do not engine coolant reservoir tank if necessary. age your vehicle. Towing instructions are avail-
open the hood further until no steam or Have your vehicle repaired at a NISSAN able from a NISSAN dealer. Local service opera-
coolant can be seen. dealer. tors are generally familiar with the applicable laws
and procedures for towing. To assure proper
4. Open the engine hood.
towing and to prevent accidental damage to your
vehicle, NISSAN recommends having a service
WARNING
operator tow your vehicle. It is advisable to have
If steam or water is coming from the en- the service operator carefully read the following
gine, stand clear to prevent getting precautions:
burned.
5. Visually check drive belts for damage or
WARNING
looseness. Also check if the cooling fan is ● Never ride in a vehicle that is being
running. The radiator hoses and radiator towed.
should not leak water. If coolant is leaking, ● Never get under your vehicle after it has
the water pump belt is missing or loose, or been lifted by a tow truck.
the cooling fan does not run, stop the en-
gine. CAUTION
WARNING ● When towing, make sure that the trans-
mission, axles, steering system and
Be careful not to allow your hands, hair, powertrain are in working condition. If
jewelry or clothing to come into contact any unit is damaged, dollies must be
with, or get caught in, engine belts or the used.
engine cooling fan. The engine cooling
fan can start at any time when the coolant ● Always attach safety chains before
temperature is high. towing.
UNDERBODY ALUMINUM ALLOY WHEELS Occasionally remove loose dust from the interior
trim, plastic parts and seats using a vacuum
In areas where road salt is used in winter, it is Wash the wheels regularly, especially during win- cleaner or soft brush. Wipe the vinyl and leather
necessary to clean the underbody regularly in ter months in areas where road salt is used. If not surfaces with a clean, soft cloth dampened in
order to prevent dirt and salt from building up and removed, road salt can discolor the wheels. mild soap solution, then wipe clean with a dry,
causing the acceleration of corrosion on the un- soft cloth. Before using any fabric protector, read
derbody and suspension. Before the winter pe- CHROME PARTS
the manufacturer’s recommendations. Some fab-
riod and again in the spring, the underseal must Clean all chrome parts regularly with a non- ric protectors contain chemicals that may stain or
be checked and, if necessary, retreated. abrasive chrome polish to maintain the finish. bleach the seat material.
GLASS Use a cloth dampened only with water to clean
the meter and gauge lens.
Use glass cleaner to remove smoke and dust film
from the glass surfaces. It is normal for glass to
become coated with a film after the vehicle is CAUTION
parked in the hot sun. Glass cleaner and a soft ● Never use benzine, thinner or any simi-
cloth will easily remove this film. lar material.
● Small dirt particles can be abrasive and
CAUTION damaging to leather surfaces and
When cleaning the inside of the windows, should be removed promptly. Do not
do not use sharp-edged tools, abrasive use saddle soap, polishes, oils, clean-
cleaners or chlorine-based disinfectant ing fluids, solvents, detergents or
cleaners. They could damage the electri- ammonia-based cleaners as they may
cal conductors, radio antenna elements or damage the leather’s natural finish.
rear window defroster elements.
● Never use fabric protectors unless rec-
ommended by the manufacturer.
● Do not use glass or plastic cleaner on
meter or gauge lens covers. It may dam-
age the lens cover.