Professional Documents
Culture Documents
2) Two infinitely large conducting plates are located at x = 1 and x = 4. The space
between them is free space with charge distribution nC/m3. Find V at x = 2 if V(l)
= -50V and V(4) = 50 V.
3) The region between x = 0 and x = d is free space and has = (x — d)/d. If V(x = 0)
= 0 and V(x = d) = Vo, find:
(a) V and E,
(b) the surface charge densities at x = 0 and x = d.
8) A conducting filament carries current I from point A(0, 0, a) to point 5(0, 0, b).
Show that at point P(x, y, 0),
9) Consider AB in figure as part of an electric circuit. Find H at the origin due to AB.
10) Plane x = 10 carries current 100 mA/m along az while line x = 1, y = -2 carries
filamentary current 20 mA along az .Determine H at (4, 3, 2).
14) Consider the following arbitrary fields. Find out which of them can possibly
represent electrostatic or magneto-static field in free space.
a) A = y (cos ax )ax + (y + e-x)az
b) B =
c) C = r2 sin
19) If = 2 o for region 1 (0 < < ) and 2 = 5 o for region 2 ( < < 2 ) and
B2 = 10 + 15 - 20 az mWb/m2. Calculate:
(a) B1
(b) the energy densities in the two media.
21) Consider the loop of figure below If B = 0.5az Wb/m2, R = 20 Ω, l= 10 cm, and the rod is
moving with a constant velocity of 8ax m/s, find
(a) The induced emf in the rod
(b) The current through the resistor
(c) The motional force on the rod
(d) The power dissipated by the resistor.
22) A conducting bar can slide freely over two conducting rails as shown in Figure above.
Calculate the induced voltage in the bar
(a) If the bar is stationed at y = 8 cm and B = 4 cos 106t az mWb/m2
(b) If the bar slides at a velocity u = 20 ay m/s and B = 4az mWb/m2
(c) If the bar slides at a velocity u = 20ay m/s and B = 4 cos (106t - y) az mWb/m2
Solution:
(a) In this case, we have transformer emf given by
The polarity of the induced voltage (according to Lenz's law) is such that point P on the bar
is at lower potential than Q when B is increasing.
(b) This is the case of motional emf:
(c) Both transformer emf and motional emf are present in this case. This problem can be
solved in two ways
Method 1:
because the motional emf is negligible compared with the transformer emf. Using
trigonometric identity
23) A parallel-plate capacitor with plate area of 5 cm2 and plate separation of 3 mm has a
voltage 50 sin 103t V applied to its plates. Calculate the displacement current assuming
=2 .