a. 8051 b. 8086 2. in open loop output is a. dependent on input b. independent of input 3. derivative of dQ/dt is know as a. current b. voltage c. charge 4. transmission voltage for 20 to 25 km line is a. 11kv b. 33 kv c. 200 kv 5. to reduce the conductor material in transmission voltage we do( actual question was lengthy, this is summarized) a. double the voltage b. do nothing etc 6. which one is correct for synchronous generator a. rotation is same as rotating magnetic field of stator 7. A voltage source conecting series resister is to be converted to current source havng resister parallel with. we use a. voltage transformation b. current transformation C.Source transformation 8. Close loop control system is term related to : I marked "error sensing" . 9. 10000MW consumes 3 millions of coal anually is equivalent to nuclear pants's enriched uranium carbon oxide ? A. 1_5 kg UCO2 B. 10-15 kg 4. Pressure of airblast CB : 10-30 KG/M2 10. function of counter register ? Program Counter (PC) holds the address of the next instruction to execute 11. Difference between FM &AM ? don't remember options 12. definition of generator. 13. 33 kv and 66 kv voltages? a)minor transients b)subtransient c)flutter voltages d)subtransmission voltages
14. diac is a 2 terminal ?
a) 4 layer device b)3 layer c)bidirectional 15. inverse of even function? a) even b)odd c)linear d)doesn’t exist 16. The dynamic system with no input is lyapunov stability 17. superposition equivalent? a) norton b) thev C) both 18. kcl ? a) current entering and leaving is zero b)Negative C)positive 19. t/x voltage? a) 110 kv B)250 kv C)400 kv D)500 KV
20. y' + 2x is equal 4 (x+1)2 ?
a) first order b)2nd order C)quadratic
21. vS Equal Ns dphi/dt?
a) lenz law b) faraday c) columbs
22. for two boolean i/p values,variables?
a)16 b)8 c)4 d)2 23. Alternator eddy current is A)directly proportional to thicknes B)inversily proportional to thickness C)square of thickness D)cube of thickness 24. rectifier with operatinal amplifier a)passive b)active c)saturated D)non saturated 25. Dynamic controller A)PID B)harolap C)lyepor etc 26. Aeroderivative turbine does not have A)fan B)fuel intake system 27. for open interval function we use A)derivative B)not derivative C)dependent D)independent 28. LANGUAGE USED IN house wiring automatic control is C++ , assembly, Ladder logic, basic, fortran 29. Moderator used in nuclear power plant = graphite 30. Air blast circuit breaker has pressure range 2-3, 20-30, 200-300, 2000-3000 31. For inductors in parallel 10mH, 10.5mH, 20mH, 20.5mH, equivalent inductance=3.4 32. For inductors in series 10mH, 20,mH, 25mH, 5mH, equivalent inductance= 60mH
33. Shunt generator has shunt winding in parallel with armature winding. The advantage is: Only require one exciter, does not require exciter,
34. Leakage inductance in transformer is made
high, low, zero, medium 35. The machine used to generate induce current by the mechanical output transformer, generator, motor, 2 more options 36. Avogedro number wala numerical 37. Which of the following is incorrect about BJT and FET both are good switching device, power consumption is high other options???? 38. Difference between amplitude modulation (AM) and frequency modulation (FM) options??? 39. Inverting Amplifier wala numerical + diagram whose options are 12, -12, 6, -6, 0 40. Which of the following is normal operation of n-p-n transistor emmitor to base junction is forward biase and collector to base junction reverse biase emmitor to base junction is forward biase and collector to base junction forward biase emmitor to base junction is reverse biase and collector to base junction reverse biase emmitor to base junction is reverse biase and collector to base junction forward biase 41. Partial derivative of fxy and fyx are called proper derivative, improper derivative, mixed derivative, universal derivative 42. _______ of fxy and fyx are simultanous mixed derivative derivative, integral 43. 1/cosinx this equation is called (equation) eular , dilichit, gibbs (something like that), other options????? 44. Plant has maximum load of 325MW, capcity of 350MW, average load is 250MW, load capacitve factor is 0.65. load factor is: 0.8, 0.67, 0.5 45. Fourier transform of continues time function gives continues frequency continuous time response, discrete frequency discrete time response, discrete frequency continuous time response, continues frequency discrete time response 46. If large load is disconnected suddenly from power plant, then: turbine speed will increase and frequency increase turbine speed will decrease and frequency decrease 47. If power plant fail to give power to particular area due to large load, it is refer to: load shadding (options) 48. The function having infinite value open, close, dependant, indepandant 49. White noise 50. time shift and time scale 51. f[x]=f[x-xn] shift right, shift left 52. optical device measure refraction drummeter, durameter, opto , declipmeter 53. probability of number 2 when dice is thrown 1/6 54. rlc impedence under root (R2 + Xc2 + XL2) 55. r=2ohm, c=1F, L=1H in parallel, impedence 56. phasor diagram gives magnitude and phase angle 57. sum of displacement is equal to work done, equivalent displacement vector 58. _________ detects fault …… relay 59. which of the following statement is correct. A. slip ring is used in ac while commutator is used in dc B. commutator is used in ac and slip ring is used in dc C. commutator is used in both 60. Standing wave Ratio is (SWR) A.Maximum impedance to minimum impedance B.peak voltage to RMS voltage C.maximum voltage to max current D.max current to min voltg E.max voltg to min voltage 61. If R=2ohm.. L=1H and C=1F is connected....... the circuits shows A. overdamed B. underdamedp C. Critically damped D.none 62. In the following equation..... A. X<R B. X>R C. X=R 63. Conjuction x^y is know as A. Addition B. Multiplication C. Subtraction D. Division 64. In an induction motor when air gap is increased then magnetizing current increases while short circuit current will A. Decrease 2. Increase 3. Initially increase then stabilized 4. Initially decreased then stabilized 5. Remain unchanged 65. first generation devices use vacuum tubes transistor 66. Oscilloscope measure A. Current B. Voltage C. Capacitance 67. In oscilloscope vertical axis represent volt/div then horizontal axis represent Ans. Time/div 68. The impedance offered by the system to the flow of negative sequence current is called negative sequence impedance . 69. Conversion stage from continues to discret is 1 ) sampling 2 ) quantization 3) decoding 70. Value of j is -1 under root (-1) 71. The fact as to how closely the instrument reading follows the measured variables is called the precision. fidelity. accuracy. sensitivity. 72. In a video channel there is modulation and ________ A.Laser B.LED 73. The direction of rotation and magnetic field are PERPENDICULAR 74. Asymptotic Stability of system is defined by (a) Eigenvalues (b)Poles & Zeros (c)response to impulse input (d)None of above 75. Differential equation of flow meter qi=Adh/dt 76. Function is ______ if lies in open interval. 77. baseband analog intensity modulation is done by modulating ______ applied to LED. 78. The ones' complement of a binary number is defined as the value obtained by inverting all the bits in the binary representation of the number (swapping 0s for 1s and vice versa) 79. In superposition theorem the voltage source is replaced by a. close circuit b. open circuit c.short circuit 80. To read bit from port P(0.1) and write it to port (3.0), instruction used is a) mov C, P0.1 mov P0.3, C 81. In closed loop system feed back strategy is : (Error Driven) a) input dependent b) error driven c) output dependent d)none 82. sampling rate must be at least ______the bandwidth of signal... equal,twice,thrice,4 times, 5 times 83. Three line shorted - symmetrical fault 84. When height of tower is increased...effect on capacitance and inductance capacitance decreases and inductance reamins same 85. In Parallel RLC circuit, If R=1, L=2, C=2, the value of natural frequency is ? 0.1 0.5 1 1.5 2 86. impedence of series RLC circuit 87. trans resistance 88. one current source 89. Fault Cause by Lighting and Storms Single line to ground fault 90. In low head power plants, Low volume & high presssure Low volume & low pressure High volume & low pressure 91. If line or load impedance decreased. X= (3R)^1/2 something (A) reduce transient (B) Reduce Line losses (C) Steady State Stability 92. In clamping circuit, we add dc level 93. Plasma frequency problem